Beruflich Dokumente
Kultur Dokumente
a. Basic type ( b.) Cellulosic Type © Rutile Type (d) Thick- coated iron powder type
a. AC (b) DC Electrode Negative (C) DC Electrode positive (D) it would make little difference
which were used
3. A code gives the acceptance standard for excess weld metal “h” as h > 1 mm + 0.1b, max. 5 mm ;
where “b” is the width of the weld cap. For which of the following situations is the excess weld metal
acceptable ?
4. A fillet weld has a design throat thickness of 8 mm .What is the minimum leg length that is required ?
a. 19.6 mm (b) 11.2 mm (c) 11.8 mm (d) it cannot be determined from the information given
5.In a martensite grain structure which opf the following mechanical properties would be increase
a.ductility
b.hardness
c.softness
d.toughness
6. Which of the following alloying elements is used to improve the toughness of steel?
(C) Being rough and torn (D) Being flat and rough
10.What is the width-depth ratio to prevent solidification crack?
a.2:1
b.1:3
c.1:4
d.1:5
(A) 35 N/mm2 yield strength (B) 35 joules @ -30 °C (C) 350 N/mm2 YIELD STRENGTH (D) 35 ksi
tensile strength
12. Large diameter pipe with a wall thickeness of 10 mm is to be used for a cross –country pipeline
.Which electrode type could be used to combine high welding speed and deep penetration?
a) Basic covered (b) Cellulosic covered (c) Rutile covered (d) Iron powder loaded
(A) Radiographic testing (B) Helium Leak Testing (C)Magnetic particle testing (D) Ultrasonic
testing
(A) The tensile strength of the weld (B) The tensile strength of the joint (C) The stress/ strain
characteristics of the weld (D) The stress /stain characteristics of the joint
15. Weldments in carbon manganese steels , made by low heat input welding , may show:
a. Greater ductility (B) higher distortion (C) higher dilution ( d}Higher hardness
16.When measuring arc voltage where should the measuring instrument be connected ?
a. Excessive distortion .
b. weld decay
c. formation of iron sulphides
a. aluminium alloys
b. carbon steels
19. Which of the following types of imperfection is generally considered to be the most serious ?
a. Surface breaking planar (b) Root concavity (C) buried planar (D) surface breaking non planar
20. Weldments in carbon manganese steels ,made using a heat input higher than the maximum
specified by.?
a. Higher integrity (B) Lower distortion (C) lower toughness ( D) Higher hardness
23.A long centerline crack has been detected in a submerged arc weld bead
c. The weld bead is deep and narrow (d) all of the above
25. Which of the following MMA electrode types is generally only suitable for welding in the PA & PB
positions ?
a. Basic b. Cellulosic c. Rutile d. High –iron powder
a.rolling
b.welding
c.cutting
d.burning
a. Travel speed (b) Polarity (c) Arc length (d) Welding current
29. From examination of the fractures faces , a ductile failure canbe identified by:
a.The presence of beach marks (B) Plastic deformation (C) Being rough and torn