Beruflich Dokumente
Kultur Dokumente
Search
866.715.7737
Menu
View My results
Question: Score 0 of 1
Response:
Paper
Feedback:
Options 3 and 4 represent hazardous materials and excavated soil, which are not a part of LEED
calculations.
Plastic
Batteries
Earth
http://www.poplarnetwork.com/edu/node/595/take 1/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Question: Score 0 of 1
Response:
Feedback:
LEED requires third party commissioning.
System designer
LEED AP
Question: Score 0 of 1
Response:
Airport
Feedback:
An airport is not a basic service, so it does not need to be within a 1/2 mile of the LEED project.
Hospital
Beauty clinic
Theater
http://www.poplarnetwork.com/edu/node/595/take 2/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Question: Score 0 of 1
Response:
They take over the area and push out other plants
Feedback:
Native or adaptive plants are adapted to the local environment and require little or no irrigation or
pesticides. They restore the ecosystem because of their indigenous nature.
Question: Score 0 of 1
Response:
Feedback:
CO2 monitoring locations should be between 3 feet and 6 feet above the floor.
Question: Score 0 of 1
http://www.poplarnetwork.com/edu/node/595/take 3/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Response:
Feedback:
The project team determines whether the LEED project boundary is a portion of the development or
the total project area, which they then submit for LEED certification. This must be consistent
throughout the calculations for all of the credits.
Built-up area
Question: Score 0 of 1
Response:
Feedback:
A green roof does not address light pollution. Xeriscaping is a strategy to address water efficiency.
Light pollution
Xeriscaping
Question: Score 1 of 1
Response:
Feedback:
The Montreal Protocol directly addresses the substances that deplete the ozone layer, including CFC,
HCFC, and halons.
Question: Score 0 of 1
Which of the following does not have high thermal emissivity and solar reflectivity?
Response:
White cement
Asphalt road
Feedback:
A high SRI value is an indicator of high solar reflectivity and thermal emissivity. White cement and
white china mosaic are high SRI materials.
Question: Score 1 of 1
What is the acceptable minimum efficiency reporting value for air filtration media to minimize and control
pollutant entry into buildings?
http://www.poplarnetwork.com/edu/node/595/take 5/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Response:
MERV 13 or higher
Feedback:
Replacing all filtration media immediately prior to occupancy with a Minimum Efficiency Reporting
Value (MERV) of 13 (as determined by ASHRAE) helps in maintaining IAQ and prevents-cross
contamination of regularly occupied areas.
MERV 8 or higher
MERV 1
MERV 5
Question: Score 1 of 1
Response:
Process water
Municipal water
Feedback:
Wastewater from toilets is always considered black water.
Question: Score 0 of 1
Response:
http://www.poplarnetwork.com/edu/node/595/take 6/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Air temperature
Feedback:
Air temperature, radiant temperature, air speed, and relative humidity are the measures of thermal
comfort.
Relative humidity
Feedback:
Air temperature, radiant temperature, air speed, and relative humidity are the measures of thermal
comfort.
Coefficient of performance
Fan speed
Question: Score 0 of 1
Which of the following refrigerants effectively addresses both direct and indirect adverse impacts on
environment?
Response:
NH3
Feedback:
NH 3 is a natural refrigerant with zero ODP (ozone depletion potential) and zero GWP (global
warming potential).
CFC
HCFC – 22
HCFC – 123
Question: Score 0 of 1
http://www.poplarnetwork.com/edu/node/595/take 7/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
What areas can be excluded from achieving the minimum daylight factor?
Response:
Copy room
Feedback:
Achieving the minimum daylight factor is not required for copy rooms, storage areas, mechanical,
laundry, and other low occupancy support areas.
Office cabins
Meeting room
Storage area
Question: Score 1 of 1
Response:
Feedback:
LEED defines heat island effect as when an urban area’s temperature is at least 10 degrees higher
than the surrounding suburban or rural areas.
Question: Score 1 of 1
Response:
28 +/- 2 deg C
Feedback:
According to ECBC (revised version May 2008) / ASHRAE 90.1-2004 standards, a factory’s whole
building simulation should use comfort temperatures of 28 +/- 2 deg C.
24 +/- 2 deg C
22 +/- 2 deg C
26 +/- 2 deg C
Question: Score 1 of 1
Response:
Bamboo extracted, processed and manufactured within 500 km of the project site
Feedback:
Regional materials are those extracted, processed and manufactured within an 800 km radius of the
project site.
Question: Score 1 of 1
Which of the following issues are addressed by the provision of adequate visitors’ parking?
Response:
http://www.poplarnetwork.com/edu/node/595/take 9/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Stormwater management
Street parking
Feedback:
Parking spaces are usually the cause of heat island effect and storm water runoff. Adequate parking
is a functional requirement. Option D is a code and not an issue.
NBC
Question: Score 0 of 1
Response:
Effects of microclimate
Building orientation
Feedback:
Options C and D, though related to energy efficiency, are predominantly indoor air quality issues.
Question: Score 0 of 1
Response:
Scheduled watering
http://www.poplarnetwork.com/edu/node/595/take 10/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Feedback:
Option 3 refers to landscape maintenance. Xeriscaping is a water-efficient landscaping practice.
Raised mowing
Xeriscaping
Question: Score 0 of 1
In order to limit disturbance and preserve natural topography of a green home site, which of the following are
considered as landscape?
Response:
Potted plants
Green roof
Walkways
Soft landscape
Feedback:
Refer to the natural topography or landscape credit under Site Selection and Planning of the IGBC
Green Homes rating system.
Question: Score 1 of 1
Which of the following is a passive design technique for optimizing energy performance?
Response:
http://www.poplarnetwork.com/edu/node/595/take 11/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Feedback:
Energy simulation is only an evaluation technique. Orientation is a passive strategy that optimizes
energy performance.
Energy simulation
Question: Score 1 of 1
Which of the following types of energy meters enhances continuous monitoring and performance of a factory
building?
Response:
Feedback:
Refer to the metering credit under Energy Conservation in IGBC’s guidelines for Green Factory
Buildings.
Question: Score 1 of 1
Response:
Infrared emissivity
http://www.poplarnetwork.com/edu/node/595/take 12/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
SRI
Feedback:
Solar reflectance index, or SRI, is the measure of a material’s ability to reject solar heat. Albedo, or
solar reflectance, is the ratio of reflected solar energy to incoming solar energy. A material with high
visible reflectance has a low solar reflectance. Infrared emissivity is the ability to emit energy by
radiation.
Visible reflectance
Albedo
Question: Score 1 of 1
Response:
Feedback:
The last option is a means of complying with light pollution reduction, not the objective. The purpose
of reducing exterior light pollution is to enhance the nocturnal environment and to increase night sky
access.
Question: Score 0 of 1
What is a brownfield?
Response:
http://www.poplarnetwork.com/edu/node/595/take 13/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Contaminated site
Feedback:
A brownfield is a damaged or contaminated site that requires cleanup.
Sustainable site
Greenfield site
Question: Score 1 of 1
Response:
Prime farmland
Constructed wetlands
Brownfield site
Feedback:
Options A, B, C are sites that are to be avoided during selection.
Question: Score 0 of 1
The performance of a factory under IGBC Green Factory Buildings is measured by which number of
categories?
Response:
http://www.poplarnetwork.com/edu/node/595/take 14/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Feedback:
Refer to the IGBC Green Factory Buildings score card.
Question: Score 1 of 1
Response:
Identify the intent, requirements, submittals and design approach for the proposed innovation credit
Feedback:
The LEED credit equivalence process is comprised of: identifying the intent of the proposed
Innovation credit, the proposed requirement for compliance, the proposed submittals to demonstrate
compliance, and the design approach used to meet the required elements.
Question: Score 1 of 1
Response:
http://www.poplarnetwork.com/edu/node/595/take 15/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
Feedback:
Options A, B, and C reduce water consumption.
“ Testimonials
I used
am soPoplar
came
for (and
happyNetwork's
outpass)
Athens.and
exam, I have
to tell youmaterial
from the
the LEED
I found
just the
and I am really excited!
straightforward
that i have
Prometric
Green
pastmaterial
to study
Centre
just
Associate
the testvery
here in
with 189
and easily digestible.
Thank you for your help. At least, here i am
-one of H.
Alec the first v4 LEED Green Associate!
- Lila Y.
http://www.poplarnetwork.com/edu/node/595/take 16/17
10/1/2014 IGBC AP Exam Practice Test - Poplar Education
http://www.poplarnetwork.com/edu/node/595/take 17/17