Beruflich Dokumente
Kultur Dokumente
Uses
Technical support
■ As a spray applied membrane to retain moisture in
Fosroc provides a technical advisory service for on-site
concrete for effective curing.
assistance and advice on admixture selection, evaluation
■ Suitable for all general concreting applications and of trials and dispensing equipment. Technical data and
particular benefit for large area concrete surfaces, such guidance can be provided for admixtures and other products
as airport runways, roads and bridgeworks. for use with fresh and hardened concrete.
Application
■ Improved curing of concrete enhances cement hydration
and provides a more durable concrete. Concure WB309 should be spray applied to the surface of
fresh concrete. Application should begin immediately the
■ Control of moisture loss improves surface quality, concrete is free from surface water. Do not apply if bleed
reducing permeability, producing a hard wearing, dust water is forming or present on the concrete surface.
free surface and minimising potential for surface
cracking and shrinkage. The spray nozzle should be held approximately 450 mm
■ Water based, therefore, non-flammable. from the concrete surface and passed back and forth to
ensure complete coverage. Pump pressure should be
■ Spray application reduces labour costs and eliminates maintained to give an even, fine spray.
the need for alternative curing systems.
After spraying, no further application of water or other
material is necessary to ensure continued curing. The
Standards compliance
concrete surface should not be disturbed until it has
sufficient strength to bear surface loads. The applied film
Concure WB309 complies with ASTM C309 as a Type 1D should not be walked on before it is fully dry and care
curing compound. should be taken to ensure that the film is not broken.
Equipment
Description
Spray equipment producing a fine mist without damaging
Concure WB309 is water based concrete curing compound the emulsion may be used for Concure WB309, such as
based on a low viscosity wax emulsion which incorporates a knapsack or motorised sprayers. The suitability of
special alkali reactive emulsion breaking system. equipment should be ensured by an application trial.
Page 1
Concure WB309
Limitations Precautions
Important note:
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions for the
Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that any advice,
recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct or continuous
control over where or how its products are applied, accept any liability either directly or indirectly arising from the use of its products,
whether or not in accordance with any advice, specification, recommendation of information given by it.
Registered Office: Industrial Area, Phase 4, Road No. 414, Street No. 407
Page 2 FO SA/CONCURE WB309/02/05