Sie sind auf Seite 1von 26

80A-1

GROUP 80A

CONFIGURATION
DIAGRAMS
CONTENTS

OVERALL CONFIGURATION  INSTRUMENT PANEL . . . . . . . . . . . . 80A-12


DIAGRAM. . . . . . . . . . . . . . . . . . . . . . 80A-2
FLOOR . . . . . . . . . . . . . . . . . . . . . . . . 80A-20
HOW TO READ CONFIGURATION 
DIAGRAMS . . . . . . . . . . . . . . . . . . . . 80A-3 ROOF . . . . . . . . . . . . . . . . . . . . . . . . . 80A-22

ENGINE COMPARTMENT. . . . . . . . . 80A-4 DOOR . . . . . . . . . . . . . . . . . . . . . . . . . 80A-24

ENGINE AND TRANSAXLE . . . . . . . 80A-8 LIFTGATE . . . . . . . . . . . . . . . . . . . . . . 80A-26


80A-2 CONFIGURATION DIAGRAMS
OVERALL CONFIGURATION DIAGRAM

OVERALL CONFIGURATION DIAGRAM


M1801000104293

Roof wiring
harness Liftgate wiring
harness
Floor wiring
harness

Instrument panel
wiring harness

Front wiring
harness

Rear door
wiring harness *

Front door
wiring harness *

Control wiring
harness Battery (-) wiring
harness

ACC04191AE

NOTE: .
1. This illustration shows only major wiring harnesses.
2. *: also equipped at the right side.

TSB Revision
CONFIGURATION DIAGRAMS 80A-3
HOW TO READ CONFIGURATION DIAGRAMS

HOW TO READ CONFIGURATION DIAGRAMS


M1801000200748
The wiring harness diagrams clearly show the connector locations and harness configurations on actual vehi-
cles. Some variations are included in one configuration diagram. Accordingly, some diagrams may not be
applicable for individual vehicles.

Denotes connector No.


The same connector No. is used throughout the circuit diagrams to facilitate connector location searches.
The first alphabetical symbol indicates the location site of the connector and a number that follows is the unique number.
Numbers are usually assigned to parts in clockwise order on the diagram.
Example: A-19
Number specific to connector (serial number)

Connector location site symbol


A: ENGINE COMPARTMENT E: ROOF
B: ENGINE AND TRANSAXLE F: DOOR
C: INSTRUMENT PANEL G: LIFTGATE
D: FLOOR

Denotes ground point. A-19


Same ground number is used throughout circuit
diagrams to facilitate search of ground point.
Refer to GROUP 70 COMPONENT LOCATIONS
-GROUND MOUNTING LOCATIONS for details
of ground points.

FRONT
Denotes harness name. WIRING
HARNESS
(RH)

A-18
Denotes a section covered by a
corrugated tube.

A-17

The mark shows the


standard mounting position
of wiring harness.

Denotes the color of the tube A-16


(If not specified, it is black).
R: Red
Y: Yellow Y

The number of connector pins and the connector color


(except milk white)* are shown for ease of retrieval.
Example: (2-B) A-15
Connector color
(milk white if no color is indicated) A-15 (2) FOG LIGHT (RH)
A-16 (2-GR) HORN (LOW)
Number of connector pins A-17 (2-B) HEADLIGHT (RH)
A-18 (2-B) WINDSHIELD WASHER MOTOR
*: Typical connector colors A-19 (2-GR) DUAL PRESSURE SWITCH
B: Black BR: Brown
Y: Yellow V: Violet
L: Blue O: Orange
G: Green GR: Gray Indicates the device to which the
R: Red None: Milk white connector is connected.

AC208446BO

TSB Revision
80A-4 CONFIGURATION DIAGRAMS
ENGINE COMPARTMENT

ENGINE COMPARTMENT
M1801000309474

Connector
symbol A-01

A -01
thru
-38

A-29

A-38

A-28

12
11

Connector color A-27


code
B : Black
BR : Brown
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet A-26 A-25
Y : Yellow
ACC06681AB

A-01 (2-B) Side turn-signal light (RH) A-11X (4) Headlight relay (Low)
A-02 (2-B) Side turn-signal light (LH) A-12X (4) MFI relay
A-04X (4) Horn relay A-13X (4) Power window relay
A-06X (4) Cooling fan control relay (Low) A-14X (4) Starter relay
A-07X (4) Cooling fan control relay (High) A-17X (4) A/C compressor relay
A-08X (4) Fog light relay A-18X (4) Throttle actuator control motor relay
A-10X (4) Headlight relay (High) A-21 (3-B) Headlight (LH)

TSB Revision
CONFIGURATION DIAGRAMS 80A-5
ENGINE COMPARTMENT

Front wiring A-02


harness

A-04X A-06X A-07X


A-08X A-10X A-11X
A-12X A-13X A-14X
A-17X A-18X

A-32X A-33X A-34X

A-37

A-21

A-22

14

13 A-23

A-24

ACC06682AB

A-22 (2-B) Position light (LH) A-29 (3-B) Headlight (RH)


A-23 (2-B) Front turn-signal light (LH) A-32X (4) PTC heater relay 1
A-24 (2-B) Fog light (LH) A-33X (4) PTC heater relay 2
A-25 (1-B) Horn A-34X (4) PTC heater relay 3
A-26 (2-B) Fog light (RH) A-37 (2-B) Front side marker light (LH)
A-27 (2-B) Front turn-signal light (RH) A-38 (2-B) Front side marker light (RH)
A-28 (2-B) Position light (RH)

TSB Revision
80A-6 CONFIGURATION DIAGRAMS
ENGINE COMPARTMENT

ENGINE COMPARTMENT (CONTINUED)

Connector
symbol Front wiring
harness

A -101
thru
-122

A-119

A-116

A-122

12

A-115 11

Connector color
code
B : Black
BR : Brown A-114
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet A-113
Y : Yellow
ACC06681AC

A-101 (2-GR) Brake fluid level switch A-106 (12) Joint connector (1) (integrated in relay
A-102 (5-GR) Windshield wiper motor box)
A-103 (3-B) Brake vacuum sensor A-107 (2-B) Front wheel speed sensor (LH)
A-104 (13) Front wiring harness and control A-108 (4-B) Spare connector
wiring harness combination
(integrated in relay box)
A-105 (1) Relay box (integrated in relay box)

TSB Revision
CONFIGURATION DIAGRAMS 80A-7
ENGINE COMPARTMENT

A-101 A-102 A-103

A-104

A-105

A-106

A-107

A-108

14

13

A-121

A-111 A-110

ACC06682AC

A-110 (4-GR) Cooling fan motor A-115 (3-B) A/C pressure sensor
A-111 (2-B) Ambient temperature sensor A-116 (2-B) Front wheel speed sensor (RH)
<Vehicles with automatic air A-119 (38-B) ASC-ECU
conditioning system> A-121 (2-Y) Front impact sensor (LH)
A-113 (2-B) Spare connector <Vehicles with KOS> A-122 (2-Y) Front impact sensor (RH)
A-114 (2-B) Washer motor

TSB Revision
80A-8 CONFIGURATION DIAGRAMS
ENGINE AND TRANSAXLE

ENGINE AND TRANSAXLE


M1801000405242

Connector
symbol B-01 B-02 B-03

B -01
thru
-16

Grounding
cable

Connector color
code
B : Black
BR : Brown
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet B-13 B-12
Y : Yellow
ACC06684 AB

B-01 (2-B) Oil feeder control valve B-06 (2-B) Evaporative emission purge solenoid
B-02 (3-GR) No.1 ignition coil B-07 (2-B) Engine coolant temperature sensor
B-03 (3-GR) No.2 ignition coil B-08 (4-B) Heated oxygen sensor (rear)
B-04 (3-GR) No.3 ignition coil

TSB Revision
CONFIGURATION DIAGRAMS 80A-9
ENGINE AND TRANSAXLE

B-04 B-15 B-06 B-07 B-16

16

Battery (-)
wiring harness

15

Control
wiring harness

B-11 B-10 B-10 B-09 B-08 B-08


<CVT> <M/T> <M/T> <CVT>
ACC06685AB

B-09 (3-B) Camshaft position sensor B-13 (2-B) Knock sensor


B-10 (6-B) Throttle body assembly B-15 (5-B) Mass airflow sensor
B-11 (4-B) Manifold absolute pressure sensor B-16 (6-B) Linear air-fuel ratio sensor
B-12 (1-L) Engine oil pressure switch

TSB Revision
80A-10 CONFIGURATION DIAGRAMS
ENGINE AND TRANSAXLE

ENGINE AND TRANSAXLE (CONTINUED)

Connector
symbol B-101 B-102 B-103

B -101
thru
-116

Grounding
cable

Connector color
code
B : Black B-116
BR : Brown
G : Green
GR : Gray
L : Blue
None : Milk white
O : Orange
R : Red
V : Violet B-115 B-114 B-113 B-112 B-111
Y : Yellow
ACC06684 AC

B-101 (2-GR) No.1 injector B-106 (10-B) Transmission range switch <CVT>
B-102 (2-GR) No.2 injector B-107 (3-B) Output speed sensor <CVT>
B-103 (2-GR) No.3 injector B-108 (3-B) Primary speed sensor <CVT>
B-105 (3-B) Secondary speed sensor <CVT>

TSB Revision
CONFIGURATION DIAGRAMS 80A-11
ENGINE AND TRANSAXLE

B-105

16

Battery (-)
wiring harness
15

B-106

Control
wiring harness

B-110 B-109 B-108 B-107


ACC06685AC

B-109 (22-B) CVT assembly B-113 (1-B) A/C compressor and clutch assembly
B-110 (2-B) Backup light switch <M/T> B-114 (3-B) Crankshaft position sensor
B-111 (1-B) Starter B-115 (1) Generator
B-112 (1) Starter B-116 (4-GR) Generator

TSB Revision
80A-12 CONFIGURATION DIAGRAMS
INSTRUMENT PANEL

INSTRUMENT PANEL
M1801000703548

Connector
symbol C-03 C-04 C-32 C-05 C-10

C -01
thru
-37 Instrument panel
wiring harness

C-23 Junction
block

C-22

C-36
19

C-13

18 21
5 Control wiring
Connector color harness
code
B: Black
BR: Brown
G: Green
Front wiring
GR: Gray harness
L: Blue 17
None: Milk white
O: Orange
R: Red
V: Violet
Y: Yellow
ACD03456AB

C-01 (22-GR) Joint connector (CAN1) C-10 (4) Joint connector (10)
C-02 (2-B) Passenger's (front) air bag module C-11 (13) Instrument panel wiring harness and
(squib) front door wiring harness (RH)
C-03 (4) IG2 relay <Vehicles with KOS> combination
C-04 (4) IG1 relay <Vehicles with KOS> C-12 (22) Instrument panel wiring harness and
C-05 (4) ACC relay <Vehicles with KOS> front door wiring harness (RH)
C-06 (20) Instrument panel wiring harness and combination
multivision display wiring harness C-13 (16-B) Data link connector
C-07 (18) Multivision display C-14 (8) Blower switch <Vehicles without
C-08 (5) Multivision display automatic air conditioning system>
C-09 (20) Radio and CD player C-17 (10) Selector lever assembly <CVT>

TSB Revision
CONFIGURATION DIAGRAMS 80A-13
INSTRUMENT PANEL

C-37 C-08 C-34 C-06 C-24 C-26 C-25 C-35 C-02 C-07

C-30

Y C-11

C-12

C-09

C-14

C-21
Floor wiring
harness

C-29 C-28 C-27 C-17 C-31 C-18 C-01


ACD03457AB

C-18 (2) Key slot <Vehicles with KOS> C-28 (15-Y) SRS-ECU
C-21 (2) Accessory socket C-29 (30-Y) SRS-ECU
C-22 (22) Instrument panel wiring harness and C-30 (14) PTC heater control unit
front door wiring harness (LH) C-31 (9) Heated seat switch
combination C-32 (10) Instrument panel wiring harness and
C-23 (13) Instrument panel wiring harness and roof wiring harness combination
front door wiring harness (LH) C-34 (18) Radio and CD player
combination C-35 (2-O) Passenger’s (front) air bag module
C-24 (1) PTC heater (squib)
C-25 (3) PTC heater C-36 (2-B) Driver’s knee air bag module (squib)
C-26 (1) PTC heater C-37 (1) Radio antenna
C-27 (15-Y) SRS-ECU

TSB Revision
80A-14 CONFIGURATION DIAGRAMS
INSTRUMENT PANEL

INSTRUMENT PANEL (CONTINUED)

Connector
symbol C-129 C-110 C-107 C-108 C-114

C -102
thru
-132

Junction
block

Front wiring
harness

C-111
19

18 21 5

Control wiring
Connector color harness
code
B: Black
BR: Brown C-126
G: Green
GR: Gray
L: Blue
17
None: Milk white
O: Orange
R: Red
V: Violet C-124 C-125 C-119
Y: Yellow
ACD03456AC

C-102 (4) Outside/inside air selection damper C-113 (10-G) Heater control panel <Vehicles without
control motor automatic air conditioning system>
C-105 (22-GR) Joint connector (7) C-114 (5) Mode selection damper control motor
C-106 (5) Hazard warning light switch and potentiometer
C-107 (4) Joint connector (8) C-115 (1-B) Parking brake switch
C-108 (24) Combination meter C-116 (5) Inside transmission antenna assembly
C-109 (22-GR) Joint connector (9) (front) <Vehicles with KOS>
C-110 (10) Engine switch C-117 (18) Instrument panel wiring harness and
C-111 (11) Remote controlled mirror switch floor wiring harness combination
C-112 (24) Auto A/C controller assembly C-118 (10) Instrument panel wiring harness and
(A/C-ECU) floor wiring harness combination

TSB Revision
CONFIGURATION DIAGRAMS 80A-15
INSTRUMENT PANEL

C-106 C-102 C-131 C-132 C-109

C-105
Instrument panel
wiring harness

C-120

C-123

Floor wiring C-112


harness C-113

C-118 C-117 C-116 C-115 C-121


C-122
ACD03457AC

C-119 (5-G) Air mixing damper control motor and C-124 (22) Instrument panel wiring harness and
potentiometer floor wiring harness combination
C-120 (2) Fin thermo sensor <Vehicles with air C-125 (12-GR) Joint connector (6) and floor wiring
conditioning system> harness combination
C-121 (4) Heater resister <Vehicles without C-126 (12-GR) Joint connector (6) and instrument
automatic air conditioning system> panel wiring harness combination
C-122 (4) Power transistor <Vehicles with C-129 (5) ASC off switch
automatic air conditioning system> C-131 (32) KOS and OSS-ECU
C-123 (2) Blower motor C-132 (16) KOS and OSS-ECU

TSB Revision
80A-16 CONFIGURATION DIAGRAMS
INSTRUMENT PANEL

INSTRUMENT PANEL (CONTINUED)

Connector
symbol C-221 C-201 C-219 C-203 C-206 C-204 C-208 C-207

C -201
thru
-230
C-205

C-222
4

C-228
Junction
block

C-223

Front wiring
harness

19

C-227
21
5
18
Connector color C-215
code
B: Black
BR: Brown
G: Green
GR: Gray
L: Blue C-211
17
None: Milk white
O: Orange
R: Red
V: Violet C-214 C-213 C-212 C-226 C-225 C-220 C-202 C-210 C-209
Y: Yellow
ACD03456AD

C-201 (4) Joint connector (3) C-209 (26) Transaxle control module <CVT>
C-202 (12-L) Joint connector (5) C-210 (22) Transaxle control module <CVT>
C-203 (22-GR) Joint connector (CAN2) C-211 (13) Front wiring harness and floor wiring
C-204 (13-GR) Joint connector (2) harness combination
C-205 (4) Stoplight switch C-212 (18) Front wiring harness and instrument
C-206 (6-B) Accelerator pedal position sensor panel wiring harness combination
C-207 (8) Electric power steering-ECU C-213 (22-GR) Front wiring harness and instrument
C-208 (2-B) Electric power steering-ECU panel wiring harness combination

TSB Revision
CONFIGURATION DIAGRAMS 80A-17
INSTRUMENT PANEL

Instrument panel
wiring harness

Floor wiring
harness
C-230
ACD03457AD

C-214 (10) Front wiring harness and instrument C-223 (2) Clutch interlock switch (for starter
panel wiring harness combination relay) <M/T>
C-215 (18) Front wiring harness and control C-225 (35-GR) Engine control module
wiring harness combination C-226 (26-GR) Engine control module
C-219 (22-L) Joint connector (4) C-227 (28-GR) Engine control module
C-220 (22-L) Joint connector (4) C-228 (30-GR) Engine control module
C-221 (4) Spare connector C-230 (28) Hands free module
C-222 (2) Clutch interlock switch (for cruise
control system and OSS) <M/T>

TSB Revision
80A-18 CONFIGURATION DIAGRAMS
INSTRUMENT PANEL

INSTRUMENT PANEL (CONTINUED)

Connector
symbol Steering column

C -301
thru
-314
C-301 C-309 C-310

Clock spring Steering sub


wiring harness

C-313

C-312

Y
Steering switch
grounding
C-308

C-303
C-314

Instrument panel
Connector color wiring harness
code
B: Black
BR: Brown
G: Green
GR: Gray
L: Blue
None: Milk white C-302 C-306 C-307 C-311 C-304
O: Orange
R: Red
V: Violet
Y: Yellow
ACC06690AB

C-301 (10) Clock spring and steering sub wiring C-308 (10) Column switch
harness combination C-309 (2-O) Driver's air bag module (squib)
C-302 (1) Horn switch C-310 (2) Steering lock solenoid <Vehicles
C-303 (6) Ignition switch <Vehicles without without KOS>
KOS> C-311 (5) Steering wheel sensor
C-304 (7) Key reminder switch <Vehicles without C-312 (4) Steering wheel multi-function switch
KOS> C-313 (6) Cruise control switch
C-306 (10) Clock spring C-314 (2-B) Driver’s air bag module (squib)
C-307 (4-Y) Clock spring

TSB Revision
CONFIGURATION DIAGRAMS 80A-19
INSTRUMENT PANEL

INSTRUMENT PANEL (CONTINUED)

Connector
symbol
Junction block

C -401
thru
-420
C-401 C-402 C-403 C-404

ETACS-ECU
C-420

C-405

C-419
C-406

C-418 C-407

C-408

C-417

C-409

C-416 C-410

C-415

C-414 C-413 C-412 C-411

ACC06691AB

C-401 (4) Roof wiring harness and junction block C-409 (4) No connection
combination C-410 (4) Fuel pump relay
C-402 (6) Instrument panel wiring harness and C-411 (4) No connection
junction block combination C-412 (4) Rear window defogger relay
C-403 (14) Instrument panel wiring harness and C-413 (4) No connection
junction block combination C-414 (4) Blower relay
C-404 (8) Instrument panel wiring harness and C-415 (4) Heated seat relay
junction block combination C-416 (24-GR) ETACS-ECU
C-405 (13) Front wiring harness and junction C-417 (24) ETACS-ECU
block combination C-418 (10) Floor wiring harness and junction
C-406 (10) Front wiring harness and junction block combination
block combination C-419 (4) Floor wiring harness and junction
C-407 (20) ETACS-ECU block combination
C-408 (1) Front wiring harness and junction C-420 (4) No connection
block combination

TSB Revision
80A-20 CONFIGURATION DIAGRAMS
FLOOR

FLOOR
M1801003500931

Connector
symbol D-01 D-18 D-02 D-20

D
D-29

Y
Floor wiring
harness

D-27

Connector color D-31


code
B: Black
BR: Brown
G: Green
GR: Gray
L: Blue
NONE: Milk white
O: Orange
R: Red
V: Violet D-37 D-35
Y: Yellow
ACD03458AB

D-01 (3) Front door switch (RH) D-10 (3) Rear door switch (LH)
D-02 (8) Floor wiring harness and rear door D-11 (4) Joint connector (13)
wiring harness (RH) combination D-12 (2-GR) Rear wheel speed sensor (LH)
D-03 (2-GR) Rear wheel speed sensor (RH) D-13 (5) Inside transmission antenna assembly
D-04 (3) Rear door switch (RH) (rear) <Vehicles with KOS>
D-05 (6) Rear combination light (RH) D-14 (8) Floor wiring harness and rear door
D-06 (5-GR) Fuel pump module wiring harness (LH) combination
D-07 (13) Floor wiring harness and liftgate wiring D-15 (3) Front door switch (LH)
harness combination D-16 (2-B) Seat belt pre-tensioner (LH)
D-08 (8) Floor wiring harness and liftgate wiring D-17 (4) Joint connector (12)
harness combination
D-09 (6) Rear combination light (LH)

TSB Revision
CONFIGURATION DIAGRAMS 80A-21
FLOOR

D-22 D-04 D-03 D-05 D-06 D-23 D-07

7 D-08

D-36
Y

D-09

10
D-32

D-10

Y D-11

Y D-14

20

D-13

D-12

D-19 D-30 D-26 D-25 D-15 D-17 D-24 D-16 D-21


ACD03459AB

D-18 (5) Outside transmission antenna D-25 (2-Y) Side-airbag module (squib) (LH)
assembly (passenger’s side) D-26 (2) Front seat belt switch (driver’s side)
<Vehicles with KOS> D-27 (2-Y) Side-airbag module (squib) (RH)
D-19 (12-GR) Joint connector (11) D-29 (2-Y) Side impact sensor (RH)
D-20 (2-B) Seat belt pre-tensioner (RH) D-30 (4) Heated seat (LH)
D-21 (5) Outside transmission antenna D-31 (4) Heated seat (RH)
assembly (driver’s side) <Vehicles D-32 (3) Luggage compartment light
with KOS> D-35 (2) Front seat belt switch (passenger’s
D-22 (2-B) Curtain air bag module (squib) (RH) side)
D-23 (2-B) Curtain air bag module (squib) (LH) D-36 (3-B) Fuel tank differential pressure sensor
D-24 (2-Y) Side impact sensor (LH) D-37 (4-B) Occupant classification-ECU

TSB Revision
80A-22 CONFIGURATION DIAGRAMS
ROOF

ROOF
M1801003400042

Connector
symbol

E E-05 E-04 E-01

Roof
wiring harness

ACC06695AB

E-01 (3) Front dome light E-05 (5) Passenger's air bag OFF indicator
E-04 (3) Microphone unit <Vehicles with light assembly
hands-free interface system>

TSB Revision
CONFIGURATION DIAGRAMS 80A-23
DOOR

DOOR
M1801001403896

Connector
symbol FRONT DOOR

F -01
thru
-15
(Passenger's side) (Driver's side)

F-04
F-01 F-02 F-14 F-08 F-05 F-06 F-07 F-15 F-13 F-09

Front door Front door


F-10 wiring harness (RH) F-12 wiring harness (LH) F-11

ACC06696AB

F-01 (10) Door mirror assembly (RH) F-11 (2-GR) Lock/unlock switch (driver’s side)
F-02 (6-GR) Front power window motor (RH) <Vehicles with KOS>
F-04 (16) Power window main switch <Vehicles F-12 (2) Front door speaker (LH)
with safety system> F-13 (16) Power window main switch <Vehicles
F-05 (10) Front door lock actuator (RH) without safety system>
F-06 (10) Door mirror assembly (LH) F-14 (4) Front power window sub switch
F-07 (6-GR) Front power window motor (LH) <Vehicles with safety system>
F-08 (8) Front power window sub switch F-15 (4) Power window main switch <Vehicles
F-09 (10) Front door lock actuator (LH) with safety system>
F-10 (2) Front door speaker (RH)

TSB Revision
80A-24 CONFIGURATION DIAGRAMS
DOOR

DOOR (CONTINUED)

Connector
symbol
REAR DOOR

F -101
thru
-108 (RH) (LH)

F-101 F-102 F-103 F-104 F-105 F-106

Rear door Rear door


F-107 wiring harness (RH) F-108 wiring harness (LH)

ACB04364AE

F-101 (8) Rear power window sub switch (RH) F-105 (2-B) Rear power window motor (LH)
F-102 (2-B) Rear power window motor (RH) F-106 (10) Rear door lock actuator (LH)
F-103 (10) Rear door lock actuator (RH) F-107 (2) Rear door speaker (RH)
F-104 (8) Rear power window sub switch (LH) F-108 (2) Rear door speaker (LH)

TSB Revision
CONFIGURATION DIAGRAMS 80A-25
LIFTGATE

LIFTGATE
M1801001901765

Connector
symbol

G G-01

Liftgate
wiring harness

G-02

G-11

9
G-03

G-10

G-04
G-09

Floor
wiring harness

G-13 G-12 G-07 G-06

ACC06697AB

G-01 (2-B) High-mounted stoplight G-09 (2-GR) Outer tone alarm <Vehicles with KOS>
G-02 (1-B) Rear window defogger () G-10 (5) Rear view camera
G-03 (4) Rear wiper motor G-11 (1-B) Rear window defogger (+)
G-04 (2) Lock/unlock switch (liftgate) <Vehicles G-12 (2) License plate light
with KOS> G-13 (2-B) Evaporative emission ventilation
G-06 (4) Liftgate latch switch assembly solenoid
G-07 (2-B) Outside transmission antenna
assembly (liftgate) <Vehicles with
KOS>

TSB Revision
80A-26 CONFIGURATION DIAGRAMS
ROOF

NOTES

TSB Revision

Das könnte Ihnen auch gefallen