Beruflich Dokumente
Kultur Dokumente
Getting started
Project configuration
Define units basis – Mass or Volume
This permits the user to select either Mass or volume based units for the input dialogues. If
volumetric units are selected the data is automatically converted to mass bases for storage
and calculation.
You can specify the conversion unit for each of the unit classes to assist in data input
Ensure that you select the correct conversion unit for your previously selected basis
Some pre-defined values are supplied which can act as the basis for your conversion
selection. Once selected the conversion value and text description can be modified to suit
your preferences.
Hydrogen Targeting
Adding a hydrogen producer
Is it a variable utility or a fixed process source? Variable utility are process such as a
hydrogen plant which can change its flowrate to meet demand. A fixed process is usually a
process operation that has fixed flowrate.
Adding a Hydrogen Consumer Unit
Use the [Insert] button to create an item. The net sink and source values are automatically
calculated.
Hydrogen Composite Curves
Hydrogen Surplus Cascade
Select source units using left mouse button. Keeping button pressed move mouse to sink
unit and then release left mouse button.
User Prompted If More Than One Source Available
The source unit (Hydrogen consumer) has both a high pressure (HP) and low pressure (LP)
source. You must select which source to use.
If Multiple Connections are From the Same Source the Split Fraction Needs to be
Specified
Double click on link leaving source (the selected link is highlighted with a “*”) to open split
fraction dialogue and enter the split fractions.
TRICK: Specify flowrate values required and it will back-calculate split fraction by
automatically normalising the input values
Once the Network is Complete It Can Be Simulated