Beruflich Dokumente
Kultur Dokumente
In this scaling project, three contours have to be programmed. All three are based on the dimensions of an original
contour, that is not machined in this project. The tool is a Æ20 mm end mill, used for a single contour at each depth.
Use a subprogram for this project and be careful when and where the scaling is turned ON or OFF.
G41
START/END POINT
0 X95.0 Y37.5
R2
ORIGINAL CONTOUR
G40
SCALE 0.9x
5,9
8,5
12
SCALE 0.7x 0
3
SCALE 0.5x
75 SQUARE
SCALED CONTOURS