Beruflich Dokumente
Kultur Dokumente
Final Exam
Review of attempt 1
Correct
Marks for this submission: 1/1.
Correct
Marks for this submission: 1/1.
1 of 4 12/7/2010 5:57 PM
DPC: Final Exam http://shukra.cedt.iisc.ernet.in/moodle/mod/quiz/review.php?q=3&attemp...
Correct
Marks for this submission: 1/1.
4 The switch that resembles most with the static characteristics of an ideal switch is
Marks: 1
Choose one a. IGBT
answer.
b. BJT
c. Thyristor
d. MOSFET
Incorrect
Marks for this submission: 0/1.
Correct
Marks for this submission: 1/1.
6 Two capacitor input filter rectifiers, A and B are designed for identical output power
of 500W. However filter A is designed for an output voltage ripple of 10% and filter
Marks: 1
B for an output voltage ripple of 20%. The applied voltage is identical for both filter
circuits. Then
2 of 4 12/7/2010 5:57 PM
DPC: Final Exam http://shukra.cedt.iisc.ernet.in/moodle/mod/quiz/review.php?q=3&attemp...
answer. a. the source power rating should be the same for both A and 7
B.
Marks: 2
b. the source power rating should be higher for A than for B.
Answer:
84.67
Correct
Marks for this submission: 2/2.
8 A buck converter operating in CCM with minimum load at 5V has the power
semiconductor devices switching at 25KHz. The operating system duty ratio is 0.5.
Marks: 2
If a 1mH inductor is used in the buck converter, calculate the input power drawn
from the source. Give the answer in watts, correct to two decimal places.
Answer:
0.25
Correct
Marks for this submission: 2/2.
9 At CT has one primary turn and 100 secondary turns. It has a core cross section
Marks: 2 area of 25 mm2. This CT is connected as a PT in the forward converter
configuration with 1 turn primary and 100 turn secondary and allowing the core flux
density to swing up to 0.2T. Core demagnetising is achieved using a schottky diode
and resistor combination connected across the primary. If the forward converter is
switched at 100KHz and 50% duty cycle, what is the output voltage of the forward
converter? (Assume all power semiconductor switches to be ideal). Give the answer
in volts.
Answer:
3 of 4 12/7/2010 5:57 PM
DPC: Final Exam http://shukra.cedt.iisc.ernet.in/moodle/mod/quiz/review.php?q=3&attemp...
Correct
50 Marks
for this
submission: 2/2.
DPC
4 of 4 12/7/2010 5:57 PM