0 Bewertungen0% fanden dieses Dokument nützlich (0 Abstimmungen)
17 Ansichten1 Seite
This document describes various measurement and reporting events related to UE measurements in 3G networks. It outlines intra-frequency, inter-frequency, inter-RAT, traffic volume, quality, and internal UE measurement reporting events that can trigger handover or configuration changes. Key events include a primary CPICH entering or leaving the reporting range (1A, 1B), a non-active cell becoming better than an active one (1C), changes in best cell quality (1D, 2A, 3D), quality thresholds being exceeded (1E, 1F, 2B, 2C, 2E, 2F, 3A, 3B, 3C), transport channel traffic volume thresholds (4A, 4B), CRC
This document describes various measurement and reporting events related to UE measurements in 3G networks. It outlines intra-frequency, inter-frequency, inter-RAT, traffic volume, quality, and internal UE measurement reporting events that can trigger handover or configuration changes. Key events include a primary CPICH entering or leaving the reporting range (1A, 1B), a non-active cell becoming better than an active one (1C), changes in best cell quality (1D, 2A, 3D), quality thresholds being exceeded (1E, 1F, 2B, 2C, 2E, 2F, 3A, 3B, 3C), transport channel traffic volume thresholds (4A, 4B), CRC
This document describes various measurement and reporting events related to UE measurements in 3G networks. It outlines intra-frequency, inter-frequency, inter-RAT, traffic volume, quality, and internal UE measurement reporting events that can trigger handover or configuration changes. Key events include a primary CPICH entering or leaving the reporting range (1A, 1B), a non-active cell becoming better than an active one (1C), changes in best cell quality (1D, 2A, 3D), quality thresholds being exceeded (1E, 1F, 2B, 2C, 2E, 2F, 3A, 3B, 3C), transport channel traffic volume thresholds (4A, 4B), CRC
RRC Reporting events or Handover events are sent from RBS or UE to trigger the different handover procedures in the RNC. The generation of handover events depend on the different RF parameters and thresholds. event 1A: A Primary CPICH enters the reporting range; addition of a radio link. event 1B: A primary CPICH leaves the reporting range; removal of a radio link. event 1C: A non-active primary CPICH becomes better than an active primary CPICH; replacement of the worst cell in AS. event 1D: Change of best cell event 1E: A Primary CPICH becomes better than an absolute threshold event 1F: A Primary CPICH becomes worse than an absolute threshold event 1G: Change of best cell (TDD) event 1H: Timeslot ISCP below a certain threshold (TDD) event 1I: Timeslot ISCP above a certain threshold (TDD)
2. Inter-frequency reporting events
Event 2a: Change of best frequency Event 2b: The estimated quality of the currently used frequency is below a certain threshold and the estimated quality of a non- used frequency is above a certain threshold; handover to inter-Freq neighbours Event 2c: The estimated quality of a non-used frequency is above a certain threshold Event 2d: The estimated quality of the currently used frequency is below a certain threshold; start compressed mode to measure inter-Freq WCDMA or GSM neighbours. Event 2e: The estimated quality of a non-used frequency is below a certain threshold Event 2f: The estimated quality of the currently used frequency is above a certain threshold; stop compressed mode & stop measure inter-Freq WCDMA or GSM neighbours
3. Inter-Rat reporting events
Event 3a: The estimated quality of the currently used UTRAN frequency is below a certain threshold and the estimated quality of the other system is above a certain threshold; handover to GSM neighbours Event 3b: The estimated quality of other system is below a certain threshold Event 3c: The estimated quality of other system is above a certain threshold Event 3d: Change of best cell in other system
4. Traffic volume measurement reporting events
event 4 A: Transport Channel Traffic Volume becomes larger than an absolute threshold event 4 B: Transport Channel Traffic Volume becomes smaller than an absolute threshold
5. Quality measurement reporting events
event 5A: A predefined number of bad CRCs is exceeded
6. UE internal measurement reporting events
event 6A: The UE Tx power becomes larger than an absolute threshold; start compressed mode event 6B: The UE Tx power becomes less than an absolute threshold; stop compressed mode event 6C: The UE Tx power reaches its minimum value event 6D: The UE Tx power reaches its maximum value event 6E: The UE RSSI reaches the UE's dynamic receiver range event 6F: The UE Rx-Tx time difference for a RL included in the active set becomes larger than an absolute threshold event 6G: The UE Rx-Tx time difference for a RL included in the active set becomes less than an absolute threshold