Beruflich Dokumente
Kultur Dokumente
I = KVn
Where I = The current in amperes
V = The voltage
K = A constant
n = A constant which shows the dependence of
the voltage V upon the current I. It is called
the voltage–dependant index
Features:
D High Transient Current Capability – up to 6500A D High Energy Capability
D Fast Response Time – less than 35ns D The Value for “n” is Greater
D Excellent Voltage Clamping Characteristics D Very Low Leakage Current
D Very Low Temperature Coefficient D Low Capacitance
D Low Standby Current D Low Overshoot Characteristics
Electrical Ratings:
Varistor Voltage
The voltage across the varistor at a DC current of 1.0mA.
Energy
The maximum electrical energy which can be dissipated within the varistor by a single impulse of 10 x 1000µs current
waveform with continuous voltage applied. Energy ratings are based on a shift of varistor voltage of less than 10% of the
initial value. The unit is expressed in joules.
Peak Current
The maximum current allowable for a single pulse of 8 x 20µs exponential waveform.
Operating Ambient Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . –40° to +85°C
Storage Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . –40° to +125°C
Response Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . less than 35ns
Voltage Temperature Coefficient . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . less than 0.05%/°C
Non–Linear Exponent
NTE1V010 to NTE1V075, NTE2V010 to NTE2V075 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 to 50
NTE1V095 to NTE1V300, NTE2V095 to NTE2V480, NTE524V13 to NTE542V48 . . . . . . . . . . . greater than 40
Maximum Leakage Current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10µA
Electrical Characteristics:
Maximum Ratings (TA = 25°C)
Characteristics
Continuous Transient
Nominal Maximum
Varistor Clamping
Voltage Voltage, VC Transient
RMS DC Energy Peak Current @ 1mA DC @ Test Current Power
NTE Type Voltage Voltage (10/1000µs) (8/20µs) Test Current (8/20µs) Dissipation
Number Case Diameter (Volts) (Volts) (Joules) (Amps) (Volts) (Volts) (Watts)
Nominal Maximum
Varistor Clamping
Voltage Voltage, VC Transient
RMS DC Energy Peak Current @ 1mA DC @ Test Current Power
NTE Type Voltage Voltage (10/1000µs) (8/20µs) Test Current (8/20µs) Dissipation
Number Case Diameter (Volts) (Volts) (Joules) (Amps) (Volts) (Volts) (Watts)
Cautions:
NTE varistors short–circuit when subjected to surges beyond their peak current and energy ratings.
NTE varistors short–circuit when operated at steady–state voltages well beyond their voltage ratings, which may eventual-
ly result in open–circuiting leaving the circuit without protection.
The following precautions should be taken to minimize this potential hazard:
D Fusing the varistor to limit high fault currents.
D Protecting the surrounding circuitry by physical shielding.
D Locating the varistor away from other components.
Typical Power Supply Circuit
100µH D
+
0.1µF 150µF
–
LS D
LL L
LD D H L LL LS LD
1V Series .345 .235 .475 1.000 .200 .024
(9.0) (6.0) (12.0) (25.4) (5.08) (0.6)
H
2V Series .699 .275 .787 1.000 .315 .031
(17.8) (7.0) (20.0) (25.4) (8.0) (0.8)
524V Series .945 .291 1.230 1.063 .394 .039
(24.0) (7.4) (31.0) (27.0) (10.0) (1.0)
This datasheet has been downloaded from:
www.DatasheetCatalog.com