Beruflich Dokumente
Kultur Dokumente
DUW:
In this article will teach you how to do DUW configuration for 3G, Ericsson DUW is new main board
from Ericsson RBS 6201 for WCDM network, Lets start DUW configuration .
Here you will learn how to configure it for different configuration and for different band.
For WCDM or UMTS 2100 band need two Ericsson DUW normally but it is depends on your
configuration requirements.
It will take some time after reloading wait for it to come up when putty will ask you to enter username
and password.
After this setup you can access primary DUW with element manger.
If you don’t have element manger in your system you can download form DUW with following steps.
IP address: 169.254.1.2
Netmask: 255.255.0.0
Gateway: 169.254.1.1
Open element manager and enter IP address of DUW.
Address: 169.254.1.1 click add
This on this step RBS will add secondary DUW configuration also this will take some time about 20
to 30 minutes.
If you don’t have moshell in your system see post Moshell Installation
Open moshell and run command “moshell 169.254.1.1”
If mounting starts you will see some percentage in result, after completing sync between both DUW
and confirm with moshell by running cabx, 2nd DUW is not in ‘standby ready’ state format 2nd DUW
and try to sync again.
Now you are able to load OaM script go to configuration and OAM configuration, chose file from
your system select automatic and run it.
Finally aAfter completion of this your site will be the visible to remote integration team.
If not visible check your OAM file IP’s and vlan’s according to your transmission plan.