Beruflich Dokumente
Kultur Dokumente
1. SCOPE
1.1 This standard lays down rolling and cutting tolerances for hot-rolled
structural steel beams, channels, equal and unequal-leg angles, tee bars,
bulb angles, round and square bars ( other than bars meant for fasteners ),
flats, plates, strips and sheets rollecl from structural steels including
medium and high strength steels.
1.2 This standard does not cover dimensional tolerances for carbon and
alloy constructional steel products which are covered by IS : 3739-1972t.
1.3 For any specific end uses, such as shipbuilding, machine components,
pressure vessels, etc, special tolerances finer than those specified in this
standard, reference shah be made to the appropriate Indian Standard
if available or otherwise these shall be as agreed to between the purchaser
and the supplier.
2. TERMINOLOGY
2.1 For the purpose of this standard, the definitions given in the appro-
priate Indian Standards on rolled steel products and those given in the
relevant parts of IS : 1956-1976$ shall apply.
4
1s : 1852- ii85
De&th Tolerance
-- __-,_h---- __-_
Over Up to and
including
mm mm mm
- 200 + 3.0
- 2.0
200 400 f 3.0
400 600 f 4.0
Width of Flange, B
------__ *-----.- --y
Over Up to and
including TM+ax y
mm mm
- 100 3.0 mm
100 250 3 percent of flange
width