Beruflich Dokumente
Kultur Dokumente
File name: \
Continuous Beam
Design code ACI 318-99
______________________________________________________________________
GENERAL INFORMATION:
Spans:
Nodes:
Distance Restraint Tx Ty Rz
[ft]
------------------------------------
0.00 Pinned 1 1 0
7.52 Pinned 1 1 0
15.04 Pinned 1 1 0
------------------------------------
Load conditions:
Reactions:
Critical deflections
Envelopes :
V2 shear forces:
Forces [Kip], Length [ft]
Vertical Translation
Deflection [in], Length [ft]
DESIGN:
Status : OK
Rebar
Longitudinal reinforcement
Transverse reinforcement
FLEXURE
Bending moments
Bending moments
Notes
* Only the design bending forces (Mu), shear forces (Vu) and torsion moments (Tu)
are
considered in the design.
* Values shown in red are not in compliance with a provision of the code
* When the moments diagram increases in the same direction of the development
length of
the bars, the bars will not contribute to the member strength for a Code specified
distance equal to max(12*db,d).
* Ld,Ldh = Development length of each bar. If the bar ends with a hook, it
considers the
Ldh length.
* sb = Free distance between top or bottom bars corresponding to the layer closest
to the
extreme face of the beam (layer1). It is not calculated when there is only one bar.
* Stirrups VCT = Flag that determines if stirrups are required to resist shear
forces (V),
torsion (T) or to confine the the longitudinal compression bars from buckling (C).
* Closed = Flag that indicates if the stirrups are closed (yes) or open (no).
* Mu/(f*Mn) = Critical strength ratio for the station. If the value is in red, it
is
larger than 1.0
* The program does not consider ACI318-99 section 12.11.3 whereby the bar diameter
is
limited according to the location of the bar cut-off.