Beruflich Dokumente
Kultur Dokumente
• Electrical isolation between input, output and power supply. TRANSDUTOR ETM 45
Technical data
Input
1 3 4 6 7 9
Precautions
Certify that the currents and voltages to be connected in to the
instrument are compatible.
The instrument must be desconnected from the eletrical instalations
before been removed.
Instalation instructions
Follow the ambient temperature band. Verify the vibration, dust, dirt
and humidity levels, that must be between the limits by the type
of case protection and climatic group, quoted in this
datasheet.
For flat surface mounting, use two M4 screws.
Voltage For top-hat rail mounting , use the fitting placed in the instrument
rear.
The connection can be done with ring shaped cable shoes or pin
shaped cable shoes terminals.
Usage instructions
After the connections been done, turn the instrument on and verify
the transducer functioning, in the output terminal.
Dimensional Drawing
Dimensions in mm
ETM 45 Data Sheet - N00326
3-phase Transducer for Alternating Current or Voltage Page 3/3
September 2002
Ordering information:
Código-No
Transducer triplo ETM-45 N 0 0 3 2 - - - - - - -
Construction
In surface mouting case 6
Rated Frequency
50Hz 1
60Hz 2
400Hz 3
Measuring range:
Voltage: 0… 10V/0 …20Vca 1
0… 21V/0… 50Vca 2
0… 51V/0… 97Vca 3
0… 98V/0…180Vca 4
0…181V/0…340Vca 5
0…341V/0…600Vca 6
Current: 0…1Aca 7
0…5Aca 8
Power supply:
20…60Vac/20…60Vdc 12
85…265Vac/90…300Vdc 13
Output signal
0…1mAcc 1
0…5mAcc 2
0…10mAcc 3
0…20mA 4
4…20mAcc 5
0…10Vcc 6
Other (by consulting) 0
Options
Error limit 0,25% 1
Standard ( without options) 5
Additional information
Complement C
Standard 1
Example:
Transducer ETM45
Construction: In surface mouting case
Frequency: 60Hz
Measuring range: 0…5Aac
Power supply: 85…265Vac/90…300Vdc
Output Signal: 4…20mA
Standard
Code number: N003262813551