Beruflich Dokumente
Kultur Dokumente
DATA SHEET
FOR
TOTAL
PREPARED/
REVIEWED BY APPROVED BY NO. OF DATE REV NO.
REVISED BY
PAGES
JC NG SUS 01.07.2012 0
SPEC OES/TD/INT/005/DS/PL02
ONSHORE ENGINEERING SERVICES
Rev. 0
DATA SHEET FOR
DISC. PIPELINE
PIPELINE BALL VALVE
PAGE : 2 OF 3
NOTES:
1. Bidder to note that the butt weld end thickness shall be calculated based
on internal pressure corresponding to pressure rating and allowable stress for
valve body material (considering specified design factor and corrosion
allowance).
2. For the welding end, the out of roundness (i.e. difference between maximum and
minimum ID at pipe end) shall be ≤0.5% of OD and tolerance on internal diameter
at pipe ends shall be same as diameter tolerance for the pipe ends indicated in
Table10, API Spec 5L, 44th edition (Effective October – 2008).
3. This valve data sheet shall be read in conjunction with Ball Valve specification .
4. Ball Mounting shall be trunnion type only.
5. Vendor shall submit valve drawings for approval.
6. For buried valves height of stem extension shall be such that centre of Actuator is 1.0
Meter above the finished ground level.