Sie sind auf Seite 1von 5

Scope Telecom Pvt Ltd

Paper-1st Date:……………………

T.T : 120 Min Max Marks: 100 Passing Marks: 75

Name:______________________ Mobile No:_________________ Email ID:________________________

Note: (a) Attempt all questions


(b) Objective type Questions carries one mark each.

Q1. As compared to AM transmitters, FM transmitters are


(A) Less efficient (B) More efficient
(C) Less costly (D) Equally efficient

Q2. In Frame structure of 4G. Value of Ts is


(A) Ts = 1/(1500 x 2048) (B) Ts = 1/(15000 x 2047)
(C) Ts = 1/(15000 + 2048) (D) Ts = 1/(1500 x 2047)

Q3. Frame loss can be reduced by:


(A) Speech Coding (B) Channel Coding
(C)Interleaving (D) Burst Formatting

Q4. In dedicated mode the BTS receives handover command on?


(A) TCH (B) SDCCH
(C)SACCH (D) FACCH

Q5. Modulation used in GSM radio interface is?


(A)Phase shift keying (PSK) (B) Gaussian Minimum shift Keying (GMSK)
(C)Frequency modulation. (D) 8PSK.

Q6. In inter BSC handover the handover is controlled by?


(A) GMSC (B) MSC
(C)Source BSC (D) Target BSC

Q7. The maximum no of neighbors that can be defined with a cell is?
(A) 8 (B) 16
(C)32 (D) 64

Q8. How many TDMA frames are there in a PDCH multiframe?


(A) 51 (B) 52
(C)26 (D) 8

Q9. Who can initiate the GPRS detach?


(A) The MS only (B) The SGSN only
(C) Both the MS and the SGSN (D) None of the above

Q10. Where is the mobility management context established in GPRS?


(A) In the MSC (B) In the SGSN
(C)In the GGSN (D) All of the above
Q11. In GSM while performing handover.
(A) The MS breaks connection from source cell and then tunes on the target cell.
(B) The MS continues connection from the source, tunes on the target and then releases the source cell.
(C) MS gets paging message from the target and replies it on its RACH and gets TCH allocated.
(D) MS gets paging message from the target and replies it on its RACH and gets SDCCH allocated.

Q12. Out of following channels which one is common channel?


(A) AGCH (B) SACCH
(C)TCH-FR (D) FACCH

Q13. In Air-interface TDMA time-slot means how many Seconds?


(A) 576.9us (B)4.615ms
(C)6.12sec (D) 6.12 us

Q14. Drop calls due to Handovers can be caused basically due to:
(A) Neighbors with Co-BSIC (B)Neighbor with Co-BCCH
(C)Neighbors with Co-BCCH and Co-BSIC (D)All of the above.

Q15. Which of the following is not a feature of GSM network alone, but also feature of analog mobile communication
network?
(A) Digital transmission of user data in air interface
(B)Possibility of full international roaming in any country
(C)Better speech quality
(D)Fully digitized switching exchange

Q16. In GSM which type of handover occurs?


(A) Hard (B) Soft
(C)Both of the above (D) Make before break

Q17. If an inter MSC handover occurs during a call, the decision to makea handover is done by

(A) BSC controlling the target cell (B) MSC controlling the target cell
(C) BSC controlling the current cell (D) MSC controlling the current cell

Q18. Which of the following is not an advantage of the GSM NETWORK? Compared to other networks which use the
same frequency band?
(A) Lower Carrier to Interference Ratio for signal reception
(B) Use of MAP signaling
(C) Frequency reuse is more efficient than in other networks
(D) Lower bit rate for voice coding

Q.19 Communication is the process of


(A) Keeping in touch (B) Broadcasting
(C) Exchanging information (D) Entertainment by electronics

Q20. In amplitude modulation


(A)The amplitude of carrier varies in accordance with theamplitude of the modulating signal
(B)The modulating frequency lies in the audio range
(C)The amplitude of the carrier remains constant
(D)The amplitude of the carrier varies in accordance withthe frequency of the modulating signal
Q21. When is location updates carried out?
(A) Every time an MS changes its location area under one MSC.
(B) Every time an MS changes between two different MSCs
(C)On a periodic basis set by a timer
(D) All of the above.

Q22. The function of Transcoder is..


(A) To convert 64 kbps speech channel on A interface to 16 kbps speech channel on A-ter Interface and vice versa.
(B)To convert 16 kbps speech channel on A interface to 64 kbps speech channel on A-ter Interface and vice versa.
(C) To convert analogue speech signal from MSC to Digital signal for use of BSC
(D) To convert analogue speech signal from BSC to Digital signal for use of MSC

Q23. The difference between phase and frequency modulation


(A) Is purely of academic interest
(B) Lies in the different definitions of the modulation index
(C) Lies in the poor audio response of phase modulation
(D) Is too great to make the two systems compatible

Q24. What identifier is used to page a GSM mobile for call delivery?

(A) TMSI (B) IMSI

(C) MSRN (D) MSISDN

Q25. In TV system, picture and sound respectively use

(A) AM,FM (B) FM,FM

(C) FM,AM (D) AM,AM

Q26. ) Being an international standard, which of these better suited for international roaming?

(A) GSM (B) CDMA

(C) NMT (D) None of these

Q27. The cell size in CDMA is ____________ compared to GSM.

(A) Larger (B) Smaller

(C)Same (D) None of the above

Q28. ) In CDMA, , the pseudo-random code must have following property

(A) It must be deterministic.


(B) It must appear random to a listener without prior knowledge of the code.
(C) The code must have a long period.
(D) All of the above

Q29. VLR and HLR in GSM systems are

(A)Gateways for outer connectivity (B) Databases of registered users

(C) Routers and call management servers (D) None of the Above
Q30. In a frequency modulation receiver, the __________ is in between the antenna and mixer.
(A)audio frequency amplifier (B) high frequency oscillator
(C)Intermediate frequency amplifier (D) radio frequency amplifier

Q31. The three main parameters against which the quality of a receiver is measured are:
(A)Selectivity, stability and frequency range
(B)Sensitivity, stability and cross-modulation
(C)Sensitivity, selectivity and image rejection
(D)Sensitivity, selectivity and stability

Q32.____________________ is a technique which transforms an analogue telephone circuit into a digital signal, involves
three consecutive processes: sampling, quantization and encoding.
(A) Frequency Modulation (FM) (B) Pulse Code Modulation (PCM)
(C) Amplitude Modulation (AM) (D) Phase Modulation (PM)

Q33.Converting data into signals by transforming and encoding the information to produce electromagnetic
signals is the functionality of a ___________.
(A) Source (B) transmitter
(C) Receiver (D) destination

Q34.What is the main reasons for using cellular systems?


(A) The main reasons are to support many users, low power and localization
(B) The main reason is profit maximization for service providers
(C) The main reasons are user localization and frequency reuse
(D)All of the above

Q 35. ) Cell Breathing is a phenomenon which occur in


(A) GSM (B) CDMA

(C) Both 1&2 (D)None of above

Q (A). Explain the difference between GSM/CDMA and WCDMA ? (5)

Q (B). Give brief explanation of GSM architecture, Features, Channels and services? (5)

Q (C)Explain the following: (6)


i)What are the advanced antenna techniques used in 4G?
ii) Difference between SIM, USIM?
iii)Why we prefer Lithium batteries, how these are better than other batteries?
iv)Explain SGSN and GGSN and on what parameters SGSN perform?
Q (D). Write formulas to calculate these numbers: IMEI, IMSI, MSRN, LAI, CGI, BSIC, you can consider
default values to calculate them? (5)
Q (E). Draw architecture of 4G? What are the advantages of 4G LTE? Explain LTE network components? (5)
Q (F). Explain Frame Structure of 4G? (3)
Q (G). Explain Evolution of communication and explain 3G architecture? (3)
Q (H). What is BTS, Node B? Explain the Difference between BTS, Node B and e Node B? (5)
Q (I). Draw the relationship between a slot, Symbol, and Resource Blocks? And also Explain Relation between
channel bandwidth, transmission bandwidth configuration and transmission bandwidth?
(5)
Q (J). Explain LTE performance and its types? (6)
Q (K). Write full forms: RJIL, TRAI,USSD, PLMN,IN, VAS, LTE, OSI, UMTS, UTRAN? (5)
Q (L). Explain GSM interfaces? (3)
Q(M). Explain common features of Wi-Max and LTE? (4)
Q(N). Explain Handover, Handoff , Roaming? (5)

Das könnte Ihnen auch gefallen