Sie sind auf Seite 1von 2

GASES

Introduction: handout 1

Substances That Exist As Gases


 Hydrogen, Nitrogen, Oxygen, Fluorine, and Chlorine exist as gaseous diatomic molecules.
 Group 8A, the noble gases are all monoatomic.
 Gases will mix evenly and completely
 Gases have lower densities than solids and liquids

Pressure of a gas
 units are derived based on velocity, acceleration and force
 Velocity is the change in distance with elapsed time; SI units: m/s but we also use cm/s
𝒅𝒊𝒔𝒕𝒂𝒏𝒄𝒆 𝒎𝒐𝒗𝒆𝒅
Velocity =
𝒆𝒍𝒂𝒑𝒔𝒆𝒅 𝒕𝒊𝒎𝒆
 Acceleration is the change in velocity with time; measured in m/s2 (or cm/s)
𝒄𝒉𝒂𝒏𝒈𝒆 𝒊𝒏 𝒗𝒆𝒍𝒐𝒄𝒊𝒕𝒚
Acceleration =
𝒆𝒍𝒂𝒑𝒔𝒆𝒅 𝒕𝒊𝒎𝒆
 Force is mass multiplied with acceleration; 1N = 1 kg m/s2
Force = mass x acceleration
 Pressure is force applied per unit area; 1 Pa = 1 N/m2
𝒇𝒐𝒓𝒄𝒆
Pressure =
𝒂𝒓𝒆𝒂
 Atmospheric Pressure: is the pressure exerted by Earth’s atmosphere; depends on location,
temperature and weather conditions
o Standard atmospheric pressure = 1 atm = 760 mmHg = 760 torr = 101,325 Pa

CONVERSIONS:
Example 1: The pressure outside a jet plane flying at high altitude falls considerably below
standard atmospheric pressure. Therefore, the air inside the cabin must be pressurized to protect
the passengers. What is the pressure in “atmospheres (atm)” if the barometer reading is 688
mmHg?

Practice 1: Convert 749 mmHg to Pa

Example 2: The atmospheric pressure in San Francisco on a certain day was 732 mmHg. What
was the pressure in kPa?

Practice 2: Convert 295 mmHg to Pa


GAS LAWS
Gases: handout 2

BOYLE’s LAW: Pressure-Volume Relationship


“The volume of a fixed amount of gas maintained at constant temperature is inversely proportional
to the gas pressure.”
PV = k1

Refer to figure on the right: 

(a) The pressure exerted on the gas by the


mercury added to the tube is equal to
atmospheric pressure
(b) Addition of more mercury results to an
increase in pressure and a decrease in gas
volume

𝟏 𝟏
𝑽 ∝ ; 𝑽 = 𝒌𝟏 𝒙
𝑷 𝑷
k1 = proportionality constant

PV = k1  P1V1 = k1 and P2V2 = k1  P1V1 = P2V2

Example 1: An inflated balloon has a volume of 0.55L at sea level (1.0 atm) and is allowed to
rise to a height of 6.5 km, where the pressure is about 0.40 atm. Assuming that temperature
remains constant, what is the final volume of the balloon?
P1V1 = P2V2
INITIAL CONDITION FINAL CONDITION
P1 = 1.0 atm P2 = 0.40 atm
V1 = 0.55 L V2 = ?

Practice 1: A sample of chlorine 1gas occupies a volume of 946 mL at a pressure of 726 mmHg.
Calculate the pressure of the gas (in mmHg) if the volume is reduced at constant temperature to
154 mL.

Das könnte Ihnen auch gefallen