Sie sind auf Seite 1von 3

1.

Camber should not exceed


a. 2 degrees
b. 4 degrees
c. 6 degrees
d. 8 degrees

2.The angle between the king-pin centre line and the vertical, in the plane of the wheel is called
a. Caster angle.
b. Camber angle
c. King pin inclination
d. Toe-out
e.
3.The purpose of caster is to give a trailing effect to the
a. front wheels
b. rear wheels
c. inner wheels
d. outer wheels
e.
4.Which device used for transmitting increased or decreased power from one shaft to another?
a. Hydraulic torque converter
b. Propeller shaft
c. Differential
d. Crankshaft

5. The amount of tilt measured in degrees from the vertical, is called


A.camber angle
B.caster angle
C. toe-in
D. toe-out

6.The purpose of valve clearance is to


a) Allow the valve to expand
b) Allow the sliding of valve in the guide
c) Ensure that the valve closes fully
d) Ensure that the crankshaft is free to rotate

7. The opening and closing of a valve is respectively done by


a) A cam and a spring
b) A spring and a cam
c) Gas pressure and cam
d) Cylinder vacuum and spring
.
8. The following is (are) the type(s) of clutch linings
(A) Solid woven
(B) Moulded type
(C) Laminated
(D) all of the above

9. The following is (are) the advantage(s) of fluid flywheel


(A) It gives a smoother power take up than centrifugal type
(B) fluid acts as a cushioning agent
(C) it needs no separate pedal or lever to operate it
(D) all of the above

10.The following type of arrangement is used in synchromesh type gear box


a. Single plate clutch
b. Fluid clutch
c. Dog clutch
d. Semi-centrifugal clutch
11. The material used for the piston of the modern cars is
a. Brass
b. Cast Iron
c. Aluminium alloy
d. Steel
12.The generator is connected in series with the battery.

13._______________ is the main source of electric energy in an automobile.

14._______________ springs are used in rear end suspension.

15. ________________ type of suspension is used in heavy duty trucks.

16. The brake shoes are curved to conform to the inner diameter of the
a. Tyre
b. Wheel
c. Pedal
d. Brake drum
17. The following is a type of leaf springs
-

(A) three Quarter elliptic


(B) semi elliptic
(C) quarter elliptic
(D) all of the above
18. The material used for making torsion bar is
(A) Steel
(B) Cast iron
(C) High carbon steel
(D) All of the above
19.__________is the correct instant for the introduction of spark near the end of compression stroke in
cycle.

20.Alternator makes noise while running due to _____________.

part –b
1 Explain in detail the bendix drive mechanism used in automobile CO3 ANALYSE & 5M
electrical system. REMEMBER

2 Explain the working of CO3 APPLYING 5M


a. mechanical brake system
b. hydraulic brake system
3 Explain about multipoint fuel injection system in SI engines. CO4 APPLYING 5M
4 What is independent suspension system? And also its purpose? CO4 CALCULATE 5M

Das könnte Ihnen auch gefallen