1- The hydrostatic pressure apparatus was placed on top of a hydraulic bench.
2- The apparatus was ensured to be installed properly as in figure 1. 3- The apparatus was levelled using the adjustable feet facilitated by the spirit level attached. 4- The counter weight was adjusted to level the balance arm in a horizontal position. 5- The drain valve was ensured to be closed and water was added slowly into the tank until the surface just touched the quadrant base, thus the datum level was established. 6- The reading of the datum level was recorded. 7- A 50g weight was placed on the balance pan and water was added slowly into the tank until the balance arm is again horizontal. 8- The mass of weight, m and the depth of immersion, d was recorded in the experimental data sheet. 9- Steps 6 and 7 was repeated with increasing weight until the tank was full of water. 10- The water was drained after the experiment was completed.