Beruflich Dokumente
Kultur Dokumente
Revision Record
Issue Changes Date
Contents
1 Overview................................................................................................................... 1
2 Interfaces................................................................................................................... 1
3 Connection and Commissioning ......................................................................... 2
3.1 Top View of M660 Demo Board ............................................................................................ 2
3.2 Bottom View of M660 Demo Board ...................................................................................... 2
3.3 Connection Cables ................................................................................................................. 3
3.4 M5X0-PWR Board ................................................................................................................ 3
3.5 Commissioning ...................................................................................................................... 4
1 Overview
M660 demo board provides a series of peripheral interfaces, including main power supply
interface, UART interfaces for commissioning and software download, and SIM card interface.
You can perform commissioning after connecting to power supply and serial ports. This document
describes only module commissioning. For details about software update, please refer to module
update document.
2 Interfaces
This demo board can be used once connected through power and serial cables.
Audio interfaces
M660 module
ON/OFF
SIM Connector
Connected to antenna
The above figure shows an M5X0-PWR board, which supplies 3.8V/0.6A power for the module
and outputs 3.3 V CMOS level TXD and RXD for the communication between the computer and
the module and software update. It is connected to the M660 demo board through 4-pin cables,
which have been soldered to the power board in a sequence of red, black, yellow, and green at one
end and should be inserted into the plug of the demo board at the other end. There are two pins on
the power board and they can control the power supply of the module.
Among the 4-pin cables:
Green: TXD, output, 2.85 V CMOS level
Yellow: RXD, input, CMOS level, 3.1 V maximum
Black: Ground
Red: VBAT, 3.6 V to 4.3 V, 3.9 V is recommended
If you want to use this power board to commission the module through serial port on a computer,
install a driver for USB to serial (PL2303 Windows Driver). If you want to use an MCU to control
the demo board, you also need to use the 4-pin cables.
3.5 Commissioning
Perform product commissioning directly on a computer through the USB interface. The power
board and demo board are connected as shown in the following figure.
USB interface
M660 demo board
Before the commissioning, you must install the PL2303 Windows Driver. Then, connect the demo
board to a computer as shown in the following figure.
If Prolific USB-to-Serial Comm Port (COM) is displayed under Ports (COM&LPT1) in the
Device Manager pane of the Computer Management window, the serial port is read properly.
Serial Port
Step 2 Select Serial from the Protocol dropdown list. The following dialog box is displayed.
Step 3 After setting parameters, click Connect. The port commissioning window is displayed.
4 Material List
M660 demo board (including module/excluding module)
M5x0-PWR board
Power and serial cables
Audio interface (optional)
GSM antenna (optional)