Beruflich Dokumente
Kultur Dokumente
Switch>enable
Password:
Switch#configure terminal
Enter configuration commands, one per line. End with CNTL/Z.
Switch(config)#vlan 100
Switch(config-vlan)#name PrvaGrupa
Switch(config-vlan)#ex
Switch(config)#vlan 110
Switch(config-vlan)#name DrugaGrupa
Switch(config-vlan)#ex
Switch(config)#interface range fastEthernet 0/1-9
Switch(config-if-range)#switchport access vlan 100
Switch(config-if-range)#ex
Switch(config)#interface range fastethernet 0/10-19
Switch(config-if-range)#switchport access vlan 110
Switch(config-if-range)#ex
Switch(config)#interface vlan 100
Switch(config-if)#
%LINK-5-CHANGED: Interface Vlan100, changed state to up
Switch(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface GigabitEthernet0/1, changed state to
down
Switch(config-if)#copy run
Switch(config-if)#copy running
Switch(config-if)#ex
Switch(config)#copy run
Switch(config)#ex
Switch#
%SYS-5-CONFIG_I: Configured from console by console
Switch#copy run
Switch#copy running-config
% Incomplete command.
Switch#copy running-config start
Switch#copy running-config startup-config
Destination filename [startup-config]?
Building configuration...
[OK]
Switch#