Beruflich Dokumente
Kultur Dokumente
NONE
HDS Confidential 1 of 2
Contents Controller failure may occur with “Micro program error [ISD] or “Micro program error [ISM]
message during ISCSI heat run. Due to the microcode bug in the abort sequence of ISCSI
command, controller failure may occur with improper error detection.
3) Controller failure DF700S/XS (AMS200 or WMS100) of 2port I/F option after pulling cable
Item Description
Contents Due to the microcode bug in the abort sequence of data transfer after pulling out the path cable,
controller failure may occur with improper reference of internal control table.
Problem may occur when all the following conditions are met.
A) DF700S(AMS200) or DF700XS(WMS100)
B) 2 port I/F option is used
C) FC cable is pulled out
5) Booting failure after executing offline code update from microcode 071x/X to 0720/A or later
Item Description
Contents Due to a microcode bug on in the system area check on the 071x/x, check code on the system
area becomes an improper value, and the controller may fail by the check code error after offline
microcode update to 0720/A.
Problem may occur when all the following conditions are met.
A) DF700M(AMS500) or DF700S(AMS200)
B) In 071x/x, SNM setting, or pair setting from CCI etc…
C) Executing offline microcode update (with Web) from microcode 071x/x to 0720/A or later
without PS OFF/ON
7) Improper ENC failure and Improper Unit # on the failure message after HDU replacement .
Item Description
Contents Improper ENC failure and improper Unit # on the failure message occur after HDU replacement
which has some fibre channel port failure. Due to microcode bug on the sequence of HDU
recovery, microcode found the backend fibre channel failure improperly after HDU replacement.
HDS Confidential 2 of 2