Beruflich Dokumente
Kultur Dokumente
i05346037
Removal Procedure
NOTICE
Keep all parts clean from contaminants.
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and repair
of the product. Be prepared to collect the fluid with suitable containers
before opening any compartment or disassembling any component
containing fluids.
1. Drain the engine oil into a suitable container for storage or disposal. Refer to Operation and
Maintenance Manual, "Engine Oil - Change".
View Image
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fullt... 18.02.2019
Service Information System Seite 2 von 4
Illustration 1 g01174241
2. Remove bolts (2) . Remove engine oil pan (1) and the gasket.
Installation Procedure
Table 1
Required Tools
NOTICE
Keep all parts clean from contaminants.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fullt... 18.02.2019
Service Information System Seite 3 von 4
View Image
Illustration 2 g01174241
View Image
Illustration 3 g00612810
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fullt... 18.02.2019
Service Information System Seite 4 von 4
1. Clean the mating surface of engine oil pan (1) and the cylinder block. Apply Tooling (A) to
four areas on the sealing surface of the oil pan. The areas are Marked Location (Y) .
2. Place a new gasket and engine oil pan (1) on the cylinder block.
4. Start with Bolt (Z) and tighten all remaining bolts (2) in a counterclockwise sequence.
6. Start again with Bolt (Z) and tighten all remaining bolts in a counterclockwise sequence.
8. Fill the engine with oil to the correct level. Refer to Operation and Maintenance Manual,
"Engine Oil - Change" and Operation and Maintenance Manual, "Capacities (Refill)".
Copyright 1993 - 2019 Caterpillar Inc. Mon Feb 18 10:26:46 UTC+0100 2019
All Rights Reserved.
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fullt... 18.02.2019