Beruflich Dokumente
Kultur Dokumente
Simple to install
Maximum comfort
State-of-the-art regulation
Heating, cooling and domestic hot water
preparation – effortlessly handled with
the Splydro
The secret behind the innovative Splydro lies in the combination of an air-to-water heat
pump in a split design with an advanced version of the Hydro Tower. This enables you to
take advantage of the outside air as a free heat source with minimal resources required for
tapping into it or for installation. As a result, your residential or commercial property can
be heated, cooled and easily supplied with domestic hot water all year round.
The system consists of a compact outdoor unit that can be installed against walls, together
with an advanced version of the tried-and-tested Hydro Tower inside the building. The out-
door unit extracts heat from the surrounding air, which is then conveyed along refrigerant
pipes to the Hydro Tower where it is transferred to the heating water. Both components re-
quire minimal space for installation, meaning you can enjoy a perfectly harmonised system
for heating, cooling and domestic hot water preparation in just a few steps.
Simple to install
in perfect harmony water cylinder and buffer tank (ThermoComfort cylinder) connect-
ed in series as well as optimised pump units in a single compact
The ease with which the outside air heat source can be tapped and space-saving casing. The indoor unit is easily connected to the
means there is no need for any excavation work, boreholes or well outdoor unit via two refrigerant pipes. Thanks to the integrated
boreholes, leaving your garden perfectly intact. The outdoor unit of components for an unmixed heating circuit with a circulating
the split heat pump requires very little space, which means set-up pump in the generator circuit and consumer circuit, the required
is flexible and installation is very simple. What’s more, the low- heating water flow rate is ensured and trouble-free operation is
speed axial fan guarantees quiet operation. Since the indoor unit guaranteed.
Maximum comfort
3
Maximum heating comfort
2
11 12
LAW 9IMR
ca. 2,5 kW 9 kW
LAW 14ITR
ca. 5,0 kW 14 kW
1 W
PM EconPlus
heat pump manager
7 Flow rate switch Cooling as an option
8 100-litre ThermoComfort cylinder
2 Heating return connection The heat pump used in the Splydro system is reversible and
9 Dirt trap
3 Heating flow connection 10 Pipe heater (2/4/6 kW)
can optionally be used to cool rooms during the hot summer
4 3
00-litre domestic hot water 11 Refrigerant pipe connection months. Excess heat is removed from the living area via exist-
cylinder with 3.2 m2
heat exchanger 12 Expansion vessel connection ing panel heating systems (silent cooling) or fan convectors
5 Liquefier (dynamic cooling) and discharged using the existing heating
6 E
lectronically controlled system.
circulating pump for heating, cooling
and domestic hot water preparation
State-of-the-art regulation
Subject to colour deviations and technical modifications without notice · AU 01/13.5 · AKOM360 Munich · DIM 164/12 · Order no. 723
Connection voltage V 230/400 400
Outdoor component width x height x depth mm 950 x 834 x 330 950 x 1380 x 330
Indoor component width x height x depth mm 740 x 1920 x 950 740 x 1920 x 950
* according to EN 14511, A2/W35: A2 = outside temperature of 2°C, W35 = heating water outlet temperature of +35°C
** cylinder temperature of 55°C and domestic hot water temperature of 45°C