Beruflich Dokumente
Kultur Dokumente
Uses Properties
Renderoc S is suitable for sprayed or trowelled
The following typical results were obtained at a water to
applications, with high build characteristics. Typical
powder ratio of 0.14.
applications would include, but not be limited to, the
following: Test method Typical result
Compressive strength : > 20 N/mm² at 1 day
All types of structural repair which can be applied by
BS1881 : Pt 116 > 40 N/mm² at 3 days
trowel or wet spray > 50 N/mm² at 7 days
Repair of structural members subjected to repetitive > 60 N/mm² at 28 days
loading including application in trafficked areas Flexural Strength : > 6 N/mm²
(BS 6319 pt 3)
Repairs to reinforced or pre-stressed beams or
columns
Wet or dry spray application - rapid application of The damaged areas of concrete to be removed must be
large quantities clearly identified. The Perimeter of the area should be saw
eping the sides square. Feather-edging is not permitted
Low rebound - when dry spray applied rebound is
and a minimum thickness of 10mm must be maintained
minimal with subsequent saving in material cost
over the whole area.
Extremely low permeability - gives excellent
The substrate should be prepared to provide a rough
resistance to attack by aggressive elements
surface having at least a 5mm amplitude at 20mm
Description
frequency.
Renderoc S is supplied as a ready to use blend of dry
If unsound or oil contaminated concrete is found to extend
powders, which requires only the addition of clean water
beyond the premarked area, consult the engineer in
to produce a highly consistent, repair mortar suitable for
charge. Subject to approval cut back to clean sound
structural concrete and masonry repairs.
concrete.
Renderoc S contains no metallic aggregate and is
If reinforcement is corroded ensure that the back of the
chloride free.
steel has been exposed. reinforcement should have all
Renderoc S is formulated for sprayed or trowelled rust removed by the use of power tools, abrasive basting
applications, in thicknesses upto 50mm in one layer by (wet or dry) or wire brushing. Reinforcing steel should be
hand application. Greater thicknesses can be achieved exposed and cleaned around it’s whole circumference.
when spray applied.
Steel should be prepared to Swedish Standard SIS 05-
900:1967-SA2½ or BS4232 Ref. 24 second quality.
Page 1
Renderoc S
Water Saturation
Add 3.5 litres of water per 25kg bag. Pour the desired Yield
quantity of water into a suitably sized mixing vessel for full Renderoc S : approx. 13 litres per 25kg bag
bag mixing. Do not use part-bags. Place 3.5 litres of cool,
Limitations
clean drinking water in the mixing container followed by
the full bag of Renderoc S and mix for 3-5 minutes, until (1) Renderoc S should not be used when the ambient
the mix becomes fully homogeneous. temperature is below 5ºC and falling.
commenced immediately either by applying Concure rinse immediately with plenty of clean water and seek
1315, or by covering the work with plastic sheet fixed over medical advice. If swallowed seek medical attention
wet hessian and taped at all edges. immediately - do not induce vomiting.
Fire
PT.FOSROC Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that any advice,
recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct or continuous control
Indonesia
over where or how its products are applied, accept any liability either directly or indirectly arising from the use of its products, whether or
not in accordance with any advice, specification, recommendation of information given by it.