Beruflich Dokumente
Kultur Dokumente
1. The condition for interface fit is that the lower limit of the shaft
a) Should be grater than the upper limit of the hole.
b) Should be greater than the lower limit of the hole.
c) Should be less than the upper limit of the hole.
d) Should be less than the lower limit of the hole.
From sheet metal of thickness 1mm, a cup of diameter 30mm and height 150mmis to
be drawn . if the limiting draw ratio is 1.8, the number of draws required are
2
3
4
5
Answers 122122234314222144132113411312