Beruflich Dokumente
Kultur Dokumente
SECTION
MODIFICATION NOTICE:
• The door trim has been changed.
• The front and rear doors have been changed.
• A front seat with side air bag has been added.
• A rear seat with 3-point center seat belt has been added.
CONTENTS
PRECAUTIONS 2 INTERIOR TRIM 5
Supplemental Restraint System (SRS) "AIR Door Trim 0 ••••••••••••••••••••••••••••••••••••••••••••••••• 5
BAG" and "SEAT BELT PRE-TENSIONER" 2 SEAT 0 ••••••••••••••••••••••••• 0 ••••••••••••••••••••••• 9 Ik.lr
DOOR 0.0 •••••••••••••••••• 0 •••• 0 ••••••••• 3 Front Seat 9
Front Door 0 ••••••••••••••• 0 ••••••••••••••••••••••••••••••••••••••••••••• 3 Rear Seat 10
Rear Door 0 ••••••••••••••••••••••••••••••••••• 4
II
BT-1
PRECAUTIONS
BT-2
DOOR
Front Door
• For removal of door trim, refer to "Door Trim" in "INTERIOR TRIM" for details, BT-5. @~
• After adjusting door or door lock, check door lock operation.
* For details of Super Lock System, refer to "POWER DOOR LOCK - Super Lock -" in EL section. ~~
SEC. 800-803-805
m
I
Door lock actuator assembly
(RHO 3-door hatchback only)
Striker
adjustment
Outside
handle
~ROd
escutcheon ") __
/~;~
~~::'
_t _
~
0.5 - 2.4 mm
(0.020 - 0.094 in)
~HOlder
II
Release lever
SBT244-A
BT.3
DOOR
Rear Door
SEC. 820-823-825
~~5.1 - 6.5
(0.52 - 0.66,
45.1 - 57.3)
Door-hinge adjustment a
~ Locking sealant
~~-~~
/ .~_==::'-J ~ 4.3 - 5.9
\ --? .' I!i3!I lJ ~ (0.44. 0.60, 38.2 • 52.1)
./ \0
0
C' ;-1-
'
~ ~~ \~' ~ ~~"
!I!i3!I
- ftt'J" 13 • 16 (1.3 - 1.6, 9 - 12)
0
"-- "'-- 1
~ I
I!i3!I \ ~~
-~~ I!i3!I ,- /tt'J 21 - 28 (2.1 - 2.9, 15 - 21)
~~ --------= ~~::::::~:::l"~~ 5.2 • 7.0 (0.53 - 0.71, 46.0 - 61.6)
I!i3!I\ \--~ ~----
Door glass adjustment
~ 5.2 - 7.0 (0.53 - 0.71, 46.0 - 61.6) _ Adjust guide rail mounting position by rotating it.
a Door-hinge adjustment
Outside handle \
escutcheon ~~
~: ..
/
; /
~':'
Striker
adjustment t-
=-/tt'J
~:3- _2~.1,
...
c1 ...@fl\\ 9 - 15)
tt'J : N. m (kg-m,
~
ft-Ib)
88T590
BT-4
INTERIOR TRIM
Door Trim
@~
REMOVAL - Door trim
3-door hatchback
~~
CD Remove inside handle escutcheon.
~ Remove power window switch, then disconnect the connector.
CID Remove screw securing pull handle and remove pull handle.
~~
@ Remove window regulator handle (Manual window models).
CID Remove screws and clips ~ securing door finisher.
<ID Lift out door finisher. ~~
~~
[p~
~~
~u
!Au
[p~
M
2m
~~
5
~u
SBTS91
~~
II
[}:{]~
~~
~[Q))A
BT-5
INTERIOR TRIM
Door Trim (Cont'd)
~J~~
• Pry open with a flatV
• Pry open with a flat- bladed screwdriver.
bladed screwdriver.
t
Metal clip
<D ~7 • Push
~Flat-bladed
~ screwdriver
@
Squeeze the regulator handle clip in place with a
screwdriver and remove the regulator handle from
the regulator shaft.
Set the regulator handle clip as shown in figure <D .
Installation
88T592
BT.6
INTERIOR TRIM
Door Trim (Cont'd)
REMOVAL - Door trim
4-door sedan and 5-door hatchback
CD Remove inside handle escutcheon.
~ Remove power window switches, then disconnect the connector.
CID Remove screw securing pull handle and remove pull handle.
@ Remove window regulator handle (Manual window models).
CID Remove screws and clips ~ securing door finisher.
CID Lift out door finisher.
~~
88T241 ~u
~~
II
[}:{]ffi\
~~
~[Q))A
BT-7
INTERIOR TRIM
Door Trim (Cont'd)
@
~J~~
• Pry open with a flatY
• Pry open with a flat- - bladed screwdriver.
t
bladed screwdriver.
CD @:ZFlat:::
{7
S
screwdriver
:
@@
Squeeze the regulator handle clip in place with a
screwdriver and remove the regulator handle from
the regulator shaft.
Set the regulator handle clip as shown in figure Q).
Installation
BT.8
SEAT
• When removing or installing the seat trim, carefully handle it to keep dirt out and avoid damage.
CAUTION: @~
• Before removing the front seat, turn the ignition switch off, disconnect both battery cables and wait
at least 3 minutes.
• Do not drop, tilt, or bump the side air bag module installed in the seat. Always handle it with care. ~~
Front Seat
MODELS WITH SRS SIDE AIR BAG
SEC. 870
~ 43 - 55
(4.4 - 5.6, 32 - 41)
~ 21 - 26
L
,
I
@@ @
\: ~-
'"--
---
----,
Jt] I
~ @(@(@@-.~_ / (;l
... -
----J I
------.I'
II
BT-9
SEAT
Rear Seat
4-DOOR SEDAN (Models with 3-point center seat belt)
/
~ Bushing
BT.10