Beruflich Dokumente
Kultur Dokumente
DATASHEET
-
PAGE
15NO03-DS-60-001
1 OF 42
LOCATION : SEMARANG
Date :
15NO03-DS-60-001 Rev. 0 DATASHEET GAS METERING SEMARANG 05/03/2015
Page : 2 of 42
REVISION SHEET
1
2
3
4
5
PENGADAAN SEMARANG GAS DISTRIBUTION PIPE LINE (CP-16)
Date :
15NO03-DS-60-001 Rev. 0 DATASHEET GAS METERING SEMARANG 05/03/2015
Page : 3 of 42
COMMENT SHEET
Rel. Humidity (%) Min. 62 Max. 96 Pressure (Psig) Min. Nor. Max. 217.36 347.89 347.89
Wet Bulb Temperature (deg F) Min.. - Max. - Vent. Press. (Psig) Min. Nor. Max. - - -
Hazardous Area Zone ZONE-0 Molecular Weight Min. Nor. Max. 16.27 16.27 16.27
Gas Group Gr IIA & IIB, T3 Mass Density (lb/ft^3) Min. Nor. Max. 0.82 1.26 1.26
Power Supply (Volt) AC/Hz 220 / 50 DC 10-30 Phase: Vapor, Liquid, Mixed Vapor
Instrument Air (min/nor/max) psig 80/100/145 T(°F) 100
Steam psig T(°C) Std. Gas Flow (MMSCFD) Min. Nor. Max. 45.07 70.98 184.97
Cooling Water (Sea Water) psig T(°C) Viscosity (cP) Min. Nor. Max. 0.01 0.01 0.01
Cooling Water (Well Water psig T(°C) Cp/Cv (k) Min. Nor. Max. 1.35 1.42 1.42
Z factor Min. Nor. Max. 0.95 0.93 0.93
Measurement Principle TCD (Thermal Conductivity Detector) Type Min/Max Pressure Range
Analysis Time (second). Max Duration Cycle Integrator Type No. of Digit
Process Connection Size Type Scale Size Range - -
Conduit Connection Size Std. Controller Range Type - -
Purge Connection Size - Type Output to PCS
Carrier Gas Cyl. & Reg. Note 2) Single/Dual Note 2) Analysis Required
Concentration (%mol) Note 6)
Zero Gas Cyl. & Reg. Note 2) Approx. Analysis Note 4) Component
COMPONENT & ANALYSIS REQUIREMENTS
Range Gas Cyl. & Reg. Note 4) Approx. Analysis Note 4) Case 1 Case 2 Case 3 Case 4 Case 5 Required Accuracy Range Units
Number of Sensors Note 4) C1 98.7100 YES ±0.5 of FS %mol
Sensor Housing Material Note 4) C2 14.0000 YES ±0.5 of FS %mol
Accuracy ±0.5% of FS C3 0.0400 YES ±0.5 of FS %mol
i-C4 0.0200 YES ±0.5 of FS %mol
n-C4 0.0000 YES ±0.5 of FS %mol
Number of Sample Stream 1 i-C5 0.0000 YES ±0.5 of FS %mol
Max. Distance Tap to Anayzer (m) Note 4) n-C5 0.0000 YES ±0.5 of FS %mol
Max. Sample Time Allowable (sec) Note 4) C6 0.0000 YES ±0.5 of FS %mol
Slipstream Bypass Flow Control C6+ 0.0000 YES ±0.5 of FS %mol
SAMPLE SYSTEM AND CONDITIONING
Stream Selection
Other Requirements Housed Prepiped NO v Manual Local - Manual Remote - Automatic
Connection Tubing Materiall 316SS Size 1/4"
Calibration Mixture
Sample Return to Vent Stack YES v Manual Local - Manual Remote - Automatic
1st level ______________________%
Measurement Alarms - YES - NO
2nd level ______________________%
Operation Alarms - YES - NO
Analyzer CHROMATOGRAPH -
Min. 75.2 Max. 87.8 Temperature (deg °F) 22.07 31.42 31.42
Wet Bulb Temperature (deg F) Min.. - Max. - Vent. Press. (Psig) Min. Nor. Max. - - -
D
E
Gas Group Gr IIA & IIB, T3 Mass Density (lb/ft^3) Min. Nor. Max. 0.82 1.26 1.26
Power Supply (Volt) AC/Hz 220 / 50 DC 24 Phase: Vapor, Liquid, Mixed Vapor
LE
Steam psig Std. Gas Flow (MMSCFD) Min. Nor. Max. 45.07 70.98 184.97
IL
T(°C)
VA
Cooling Water (Sea Water) psig T(°C) Viscosity (cP) Min. Nor. Max. 0.01 0.01 0.01
A
Y
T
Cooling Water (Well Water psig T(°C) Cp/Cv (k) Min. Nor. Max. 1.35 1.42 1.42
LI
TI
U
REMOTE RECEIVERS
Chart Drive Size Type Chart Drive Type Speed - -
Analysis Time (second). Max Duration Cycle Integrator Type No. of Digit - -
Process Connection Size Type Scale Size Range - -
IT
N
PCS
EL
Flowcomp
A
Carrier Gas Cyl. & Reg. Note 2) Single/Dual Note 2) Analysis Required
Concentration (%mol) Note 6)
Zero Gas Cyl. & Reg. Note 2) Approx. Analysis Note 4) Component
COMPONENT & ANALYSIS REQUIREMENTS
Range Gas Cyl. & Reg. Note 4) Approx. Analysis Note 4) Case 1 Case 2 Case 3 Case 4 Case 5 Required Accuracy Range Units
Number of Sensors Note 4) C1 98.7100 YES ±0.5 of FS %mol
Sensor Housing Material Note 4) C2 14.0000 YES ±0.5 of FS %mol
Accuracy ±0.5% of FS C3 0.0400 YES ±0.5 of FS %mol
i-C4 0.0200 YES ±0.5 of FS %mol
n-C4 0.0000 YES ±0.5 of FS %mol
Number of Sample Stream 1 i-C5 0.0000 YES ±0.5 of FS %mol
Max. Distance Tap to Anayzer (m) Note 4) n-C5 0.0000 YES ±0.5 of FS %mol
Max. Sample Time Allowable (sec) Note 4) C6 0.0000 YES ±0.5 of FS %mol
Slipstream Bypass Flow Control C6+ 0.0000 YES ±0.5 of FS %mol
SAMPLE SYSTEM AND CONDITIONING
Stream Selection
Other Requirements Housed Prepiped NO v Manual Local - Manual Remote - Automatic
Connection Tubing Materiall 316SS Size 1/4"
Calibration Mixture
Sample Return to Vent Stack YES v Manual Local - Manual Remote - Automatic
1st level ______________________%
Measurement Alarms - YES - NO
2nd level ______________________%
Operation Alarms - YES - NO
ANALYSIS REQUIRED
CARRIER GAS CYL® SINGLE/DUAL YES ACC. RANGE UNITS MIN NOR MAX UNITS
ZERO GAS CYL® APPROX. ANALYSIS
H2O X +/-2% 0-1 lbs H2O/MMscf gas 0.0200 lbs H2O/MMscf gas
RANGE GAS CYL® APPROX. ANALYSIS
H2S 0.0000 % mole
FURNISHED BY SELELR OR BUYER CO2 0.3500 % mole
LOCATION:FIELD, PANEL, OTHER NITROGEN 0.7200 % mole
OUTPUT RANGE TYPE METHANE 98.7100 % mole
REQUISITION NO. ETHANE 0.1400 % mole
MANUFACTURER (FOR REFERENCE) BY VENDOR PROPANE 0.0400 % mole
MODEL NO. (FOR REFERENCE) BY VENDOR i-BUTANE 0.0200 % mole
n-BUTANE 0.0000 % mole
i-PENTANE 0.0000 % mole
n-PENTANE 0.0000 % mole
n-HEXANE 0.0000 % mole
n-HEPTANE 0.0000 % mole
ANALYSIS REQUIRED
CARRIER GAS CYL® SINGLE/DUAL YES ACC. RANGE UNITS MIN NOR MAX UNITS
ZERO GAS CYL® APPROX. ANALYSIS
H2O X +/-2% 0-1 lbs H2O/MMscf gas 0.0200 lbs H2O/MMscf gas
RANGE GAS CYL® APPROX. ANALYSIS
H2S 0.0000 % mole
FURNISHED BY SELELR OR BUYER CO2 0.3500 % mole
LOCATION:FIELD, PANEL, OTHER NITROGEN 0.7200 % mole
OUTPUT RANGE TYPE METHANE 98.7100 % mole
REQUISITION NO. ETHANE 0.1400 % mole
MANUFACTURER (FOR REFERENCE) BY VENDOR PROPANE 0.0400 % mole
MODEL NO. (FOR REFERENCE) BY VENDOR i-BUTANE 0.0200 % mole
n-BUTANE 0.0000 % mole
i-PENTANE 0.0000 % mole
n-PENTANE 0.0000 % mole
n-HEXANE 0.0000 % mole
n-HEPTANE 0.0000 % mole