Beruflich Dokumente
Kultur Dokumente
COLLEGE OF ENGINEERING
DEPARTMENT OF MECHANICAL ENGINEERING
SECTION : 03
GROUP :F
GROUP MEMBER:
1. NUR SABRINA BINTI MUDA (ME0100753)
2. PAVITHARREN AL ASOGAN (ME0101225)
3. RABIANUR AIREN BINTI MOHAMED (ME0101397)
4. RUBANRAJI A/L RAJENDREN (ME099394)
5. SHASZRAN ANDZAR BIN ANNUAR (ME0100206)
6. SIVANESH RAO A/L BALARAJOO (ME099471)
To observe unsteady state conduction of the center of a solid shape when a step
change is applied to the temperature at the surface of the shape.
To investigate on the Lumped Thermal Capacitance method of transient
temperature analysis.
TABLE OF CONTENT
CONTENT PAGE
Introduction
Equipment
Procedure
Analysis
Discussion
Conclusion
References
Appendices
INTRODUCTION
OBJECTIVES
To observe unsteady state conduction of the center of a solid shape when a step
change is applied to the temperature at the surface of the shape.
To investigate on the Lumped Thermal Capacitance method of transient
temperature analysis.
EQUIPMENT AND MATERIALS
1. Equipment
Figure 3.1: Rear view of the rig setup to investigate unsteady state heat transfer (model: LS-
17 020). See next page for legend labels. photograph procured from Experimental &
Operations manual - Lotus scientific (M) Sdn. Bhd.
Figure 3.2: Front view of the rig setup to investigate unsteady state heat transfer (Model:
LS-17 020). Photo procured from Experimental & Operations Manual - Lotus Scientific (M)
Sdn. Bhd.
Legend
A Water Bath Tank H Drain Valve (DV1)
Legend
A Brass Slab 70X15X75mm E Brass Sphere OD=45mm
Specimen Specimen
B Stainless Steel Slab 70X15X75mm F Stainless Steel Sphere
Specimen OD=45mm Specimen