Beruflich Dokumente
Kultur Dokumente
July 2012
Edition 1
510166 AA
lectra.com 1/7
VOYAGER™ 1202G BARCODE READER
HYPERION 1300G BARCODE READER
Installation and configuration
PREFACE
Copyright
© LECTRA 2010-2012. All Rights Reserved. Any copying, reproduction or translation of all or part of the
contents of this document without the express written permission of LECTRA is strictly forbidden by the
provisions of copyright laws.
Guarantees
LECTRA reserves the right to modify, without prior notice, information relating to its products in order to
improve their reliability or operating capacity.
Publication does not imply that the contents are free of industrial patent rights and does not grant
permission in any other respect to those rights. LECTRA assumes no liability for the consequences of
using this information in any way whatsoever.
Performances and other data appearing in this documentation are approximate and have no contractual
value.
Registered trademarks
Voyager™ is a registered trademark of Honeywell International Inc, USA.
Update monitoring
Edition 1
Creation of the document
July-2012
This document describes how to configure the Voyager™1202G reader and Hyperion 1300G reader
for barcode reading in Lectra applications. This reader has been validated with the following software:
• LeatherScan
• LeatherSupervisor
• LeatherManager
• GPDirectScan
This document is intended for Lectra training staff and technical personnel.
This document gives the detailed procedure to configure the barcode reader before first use.
This scanner CANNOT read barcodes from an LCD monitor so you must print pages containing configuration barcodes.
Contents
1. Installation and initialization ................................................................................................................... 5
2. RS-232 interface selection....................................................................................................................... 6
3. GPDirectScan Configuration ................................................................................................................... 6
4. Operating test ........................................................................................................................................... 7
4.1 Test with LeatherSupervisor (or LeatherScan) ................................................................................ 7
4.2 Test with GPDirectScan ................................................................................................................... 7
To correctly install the barcode reader, follow these two steps in order.
Voyager 1202G
Hyperion 1300G
To reduce the barcode reader beep volume, scan the following barcode:
To increase the barcode reader beep volume, scan the following barcode:
3. GPDIRECTSCAN CONFIGURATION
For GPDirectScan which requires the CR terminator, read the following barcode:
4. OPERATING TEST
1 Launch GPDirectScan.
2 Open the Configuration dialog box.
3 Select the right COM port.
4 Read the test codes below in the Sample field.