Sie sind auf Seite 1von 5

1.

Radio frequency cannot be seen because


The sensitivity are below the human eye
3. The characteristic impedance of a long transmission line may be determined by using which of the
ff. Methods.
Adding impedance to successive short sections
5. BW? Given: 30pF, 2kW SOL: BW = 1/4RC
3 MHz
6. Given: 138 cons 1 =assume .5 outer diameter .2 inner diameter Char. Impedance of coax cable
chemele?
138/1 x log .5/.2=
54.92

10. A circulator:
Allows a receiver and a transmitter to share the same antenna.
12. Where is maximum current located at Marconi antenna
Base of antenna
13. What is the effect of adding a capacitor in series with an antenna?
The antenna's reasonance freq. Will increase
15. Interference caused by one channel to another channel
Crosstalk
16. Given: T=1090K, Find: ENR; ENR(dB) = 10 log ((1090-290)/290)
4.41 dB
18. The refractive index of 10 million electrons given 10MHz is ___
19. Proposed the geostationary scheme or orbit
Arthur Clark
20. The importance of Impedance matching in transmission line.
For maximum power transfer
21. Is a measure of loss of energy of a capacitor.
Dissipation Factor
23. The minimun number of geostationary satellites required for a global coverage.
3
25. Why does uplink have high frequency than downlink
Provides narrow beam shining into space
28. What is the time travelled by the sound wave distance 5km
14. 18 s
30. Ultra High frequency are normally propagated by
Space waves
31. A TDM system
Give low Signal-to-Noise Ratio
33. The most effective frequency at a specified time for ionospheric propagation of radio waves
between two specified points
Optimum Working Frequency
35. Beam width angle is __ the dish diameter.
Decrease with increase in
36. Given tower heights 40m and 20m, what is the total transimission distance
Sqrt(17(towerht)) Sqrt(17(20))+sqrt(17(40))
45km
37. Cut off frequency of te10 with inside cross section area of 2
3.75GHz
40. In a waveguide, ____ is specific configuration blablabla
Mode
41. What is the gain of simple dipole isotropic antenna
1.74dB
43. Which of the stages increases the selectivity of the circuit in an am receiver?
IF stage
44. Troposcatter propagation
Fading
45. An ungrounded antenna near the ground
Acts as an antenna array
49. Ionosphere average height of 225km at night
F2 Layer
50.
52. PIN 21 of the RS232
Signal quality factor
55. 64kbps error checking tas may BISDN
Asynchronous transfer mode
57. Reliable convolutional
Cyclic redundancy check
58. A simple phasor diagram except that Entire phasor is not drawn
Constellation diagram
59. Maximum distance of 100BaseT
100 meters

62. An effect characteristic of current distribution in a conductor at high frequencies by virtue of which
the current is greater near the surface of the conductor than in its interior resulting in an increase of
resistance with increasing frequency (almost ganito yung thought)
Skin effect
63. Given: 3 MV/m, what is the maximum power density?
23.9 x 10^6 W (Ps = (3MV)^2/377)
*constant yung 377(120*pi)
65. Factors affecting the characteristic impedance of parallel conductor
Size of conductor and spacing between conductor
67. The term balun refers to
Balanced to Unbalanced
70. Blah blah blah can be calculate through smith chart
The impedance among transmission lines.
71. When characteristic impedance matched the output impedance of trans line and similar to the
impedance puchu of the antenna.
Maximum power transfer will take place
73. What is the process of extracting a phase coherent source into.
Carrier recovery
75. A transmission line terminated with a short ckt has an equivalent (impedance? Nakalimutan ko
yung specific na tinanong) at 1/4 wavelength away from termination.
Parallel-resonant
76. Most widely used UJT
CAT 5
77. Modulated = 125V Unmodulated carrier=85v What is the modulation index
0.47

81. Measures the input–output gain of a detector system. In the specific case of a photodetector.
measures the electrical output per optical input.
Responsivity
82. Linear-beam vacuum tube, which is used as an amplifier for high radio frequencies, from UHF up
into the microwave range.
Klystron
83. The reference model describes how data is send and received over a network. The model
provides the standard for communications so that different manufacturer's computers can be used on
the same network.
OSI
84. Interference caused by one channel to another channel
Crosstalk
85. What do you call the additional accumulation of sounds such as wind, street noise and ...... that
contributes to what the listener hears?
Ambience
89. The lighting rod must be mounted at the top at least ______cm above highest point.
30
90. Antenna with one connected to a transmission line and others are not
Parasytic Antenna Array
91. Above the earth surface which retractable and the body is reflected
Ans: diko po maalala parang may Bi something
Sensiya napi kulang kulang diko makita sa net
92. What LEO constellation is up to date?
Teledesic
95. Definition of TE20 mode
TE20
99. Wavelength of wave in waveguide is
Greater than in free space
Redundancy.. characters are combined together…
Checksum
When a quarter-wave section transmission lone is terminated by a short circuit and is connected to an
source at the other end, its input impedance is
A. Inductive B. Capacitive C. Resistive ANS D. Equivalent to a parallel resonant LC circuit
Find ... Given noise factor of 2 db ... And power gain 10 db.
2.15
Given antenna diameter 8m and frequency 8Mhz
SOL'N : d = (2D^2)/lambda
3.4 m

Das könnte Ihnen auch gefallen