Beruflich Dokumente
Kultur Dokumente
com
KA2S0680B
Fairchild Power Switch(SPS)
Features Description
• Wide operating frequency range up to 150KHz The SPS product family is specially designed for an off-line
• Pulse by pulse over current limiting SMPS with minimal external components. The SPS consist of
• Over load protection high voltage power SenseFET and current mode PWM Control-
• Over voltage protection (Min. 23V) ler IC. PWM controller features integrated fixed oscillator,
• Internal thermal shutdown function under voltage lockout, leading edge blanking, optimized gate
• Under voltage lockout turn-on/turn-off driver, thermal shut down protection, over volt-
• Internal high voltage sense FET age protection, temperature compensated precision current
• External sync terminal sources for loop compensation and fault protection circuit.
• Latch up Mode Compared to discrete MOSFET and controller or RCC switch-
ing converter solution, a SPS can reduce total component count,
design size, weight and at the same time increase & efficiency,
productivity, and system reliability. It has a basic platform well
suited for cost effective design in monitor power supply.
TO-3P-5L
#3 VCC
32V 5V Internal #1 DRAIN
Vref bias SFET
Good
logic
#5 Sync −
+ OSC
5V
S
6.4V Q
R
#4 FB −
L.E.B
2µA 1mA 2.5R +
9V 1R
0.1V
+
7.5V − S #2 GND
Q
R
+ Thermal S/D
25V − Power on reset
OVER VOLTAGE S/D
Rev.1.0.1
©2001 Fairchild Semiconductor Corporation
KA2S0680B
2
KA2S0680B
Note:
Pulse test: Pulse width ≤ 300µS, duty cycle ≤ 2%
1
S = ----
R
3
KA2S0680B
Notes:
1. These parameters, although guaranteed, are not 100% tested in production
2. These parameters, although guaranteed, are tested in EDS (wafer test) process
3. The amplitude of the sync. pulse is recommended to be between 2V and 3V for stable sync. function.
4
KA2S0680B
5
KA2S0680B
Figure 11. Shutdown Delay Current Figure 12. Over Voltage Protection
6
KA2S0680B
Figure 13. Soft Start Voltage Figure 14. Static Drain-Source on Resistance
7
KA2S0680B
Package Dimensions
TO-3P-5L
8
KA2S0680B
TO-3P-5L (Forming)
9
KA2S0680B
Ordering Information
Product Number Package Rating Operating Temperature
KA2S0680B-TU TO-3P-5L
800V,6A -25°C to +85°C
KA2S0680B-YDTU TO-3P-5L(Forming)
TU : Non Forming Type
YDTU : Forming Type
10
KA2S0680B
11
KA2S0680B
DISCLAIMER
FAIRCHILD SEMICONDUCTOR RESERVES THE RIGHT TO MAKE CHANGES WITHOUT FURTHER NOTICE TO ANY
PRODUCTS HEREIN TO IMPROVE RELIABILITY, FUNCTION OR DESIGN. FAIRCHILD DOES NOT ASSUME ANY
LIABILITY ARISING OUT OF THE APPLICATION OR USE OF ANY PRODUCT OR CIRCUIT DESCRIBED HEREIN; NEITHER
DOES IT CONVEY ANY LICENSE UNDER ITS PATENT RIGHTS, NOR THE RIGHTS OF OTHERS.
www.fairchildsemi.com