Sie sind auf Seite 1von 1

7.

2  Installation of the Exhaust Gas


Recirculation Crossover Tube
Install as follows:
Show/Hide Checkboxes
1. Install a new Exhaust Gas Recirculation (EGR) connector tube (if required) into the EGR cooler
and install the EGR crossover tube and the lifting eye onto the cylinder head.
2. Loosely install the six bolts to the EGR crossover tube.
3. Install the bolt attaching the EGR crossover tube to the coolant crossover tube. Torque to 30
N·m (22 lb·ft).
4. Install the bolt attaching the coolant crossover tube to the EGR crossover tube. Torque to 30
N·m (22 lb·ft).
5. Tighten the six EGR crossover tube bolts to the cylinder head. Torque to 60 N·m (44 lb·ft).
6. Install the venturi pipe to the EGR crossover tube with a new gasket and two bolts. Torque the
bolts to 30 N·m (22 lb·ft).
7. Using soap and water for ease of installation, slide the connector hose from the mixer pipe onto
the venturi pipe.
8. Connect the delta-P sensor electrical harness connector.
9. Install the two clamps onto the hose and torque to 3.0 N·m - 3.5 N·m (26-26.5 lb·in.).

Das könnte Ihnen auch gefallen