Beruflich Dokumente
Kultur Dokumente
(3) If Oil is not available, Clean the V-Block by using Soft Paper like Towel to avoid Damages.
(4)
(5)
(3)
(4)
i.e. L = 49.95 mm to 50.05 mm; W = 24.95 mm to 25.05 mm & H = 29.95 mm to 30.05 mm.
Rejection Criteria:
(1) The Rectangular V-Block shall be Rejected if any one of the Dimensions measured is Out of Spec w.r.t. Error Acceptance Criteria.
Procedure:
(1) Place the Rectangular V-Block on to the Profile Projector's Measuring Table. Make sure that, Profile Projector is cleaned.
(2) Use Magnetic V-Block for orign alignment/parallel alignment (0-0 Coordinates) of Rectangular V-Block.
(3) Measure the Length, Width, Height and record the same in Inspection/Verification Report. At-least take a minimum of 3 Trials.
(4) Check all readings whether lies within the Specification or not.
(5) If all Dimensions are Ok, Accept the V-Block by taking Approval from QA Manager. Mention Verification Due On Date on the Report.
(6) Attach the Calibration Reports of Master Instruments to the Reports of Rectangular V-Block for Traceability.
(7) Shall collect & keep all Traceability Certificates from Lab Agency against Calibration Reports of Master Instruments.
(8) QA Manager/Calibrator shall Sign off the report as Verified & found Ok (along with Date) at the Back of Calibration/Verification Reports.
(9) If the Readings are Out of Spec, then the V-Block shall be Rejected & Scrapped in contolled manner.
(10) Rectangular V-Block can be used for a Maximum of 3 years & later shall be Scrapped as there are chances of worn-out.
Doc No.: XXX/XXX/XX | Rev No.: XX Prepared By: Mr.Name Sheet Author: Mr.Name
Rev Date: XX.XX.XXXX Approved By: Mr.Name Page: 1 of 1.
Issue No.: XX | Issue Date: XX.XX.XXXX