Beruflich Dokumente
Kultur Dokumente
Comparison Charts
Comparison with
Cooling Tower
www.frigel.com
Comparison with Cooling Tower
Productivity Productivity
• Lack of flexibility and precision in temperature • Possibility of searching and repeating the
control. optimum cooling conditions for each mold.
• Impossible to cool the water below Wet Bulb Complete independence of setting.
Temperature • Precise automatic control of the mold
• Variable water flow to molds, highly affected by temperature.
the other users. • Cooling conditions (temperature AND flow)
• Contamination and Scale Accumulation inside permanently stable and under control for
Molds Cooling Channels and TCU’s (when each mold.
used), provoking clogging and reduced heat • High cooling efficiency with low delta T of
transfer efficiency with frequent need of the process fluid through the
mechanical scale removal. mold with Lower Cycle Times
• Frequent downtimes • A much higher quality of molded parts. Less
• Higher cooling Cycle Times due to High and scraps.
Variable delta T on molds and reduced heat • Communication interfaces available with
transfer efficiency. process machines.
Installation Installation
• Complicated and costly Initial Installation for • Simple, quick and inexpensive
centralized pump-tank groups installation. No need for intricate central
• Complicated and costly Expansions pumping groups.
• No need for main pipeworks insulation
• Modular concept “Easy to expand”