Beruflich Dokumente
Kultur Dokumente
IOP xx_00
MATRIX-EVO Dashboard Panel
to confirm.
You have accessed the SAR MENU: calibration procedure can start.
1.
MACHINE MUST BE ON A FLAT GROUND, NOT BRAKED, WITH NO LOAD ON
FORKS, AND WITH ALL FOUR WHEELS ALIGNED.
Referring to the machine load chart, get a load of known weight (we suggest about
50% of maximum machine lifting capacity): i twill be used during calibration.
2.
If machine is cold, we suggest to use it a few minutes in order to warm up the gear
oil, especially if a new load cell has been fitted or the same one has been re-
positioned.
3.
Select fork mode.
4.
Press OK to confirm.
1
SAR CALIBRATION
IOP xx_00
MATRIX-EVO Dashboard Panel
5.
With no load on forks, boom completely in and fully up.
6.
Lift the load previously prepared to no more than 20 cm from the ground.
Boom out till the movement should stop (please refer to the relevant load
chart with no stabilizers)
Wait a few seconds to make any boom oscillation to stop and press OK to
confirm the second key point.
7.
Put down the load. Completely extend both front stabilizers.
With no load on forks, boom completely in and fully up.
8.
Keep the stabilizers extended.
Go down with the boom. Lift the same load as before. Keeping it at no more
than 20 cm height from the ground, boom out till the movement should stop
(please refer to the relevant load chart with stabilizers)
Sfilare fino a raggiungere il limite di ribaltamento indicato dal relativo
diagramma di portata su piedi stabilizzatori.
Wait a few seconds to make any boom oscillation to stop and press OK to
confirm the second key point.
9.
Calibration procedure is finished. The system will give you an OK confirmation.
Check the anti-tipping system and make sure that it works properly.
2
SAR CALIBRATION
IOP xx_00
MATRIX-EVO Dashboard Panel
to confirm.
You have accessed tha SAR MENU: calibration procedure can start.
1.
MACHINE SHOULD BE ON A FLAT GROUND, NOT BRAKED AND WITH NO
LOAD ON FORKS
2.
Retract the boom.
3.
Position the boom at 0°.
4.
3
SAR CALIBRATION
IOP xx_00
MATRIX-EVO Dashboard Panel
5.
6.
to confirm.
You have accessed tha SAR MENU: calibration procedure can start.
4
SAR CALIBRATION
IOP xx_00
MATRIX-EVO Dashboard Panel
1.
MACHINE SHOULD BE ON AN HORIZONTAL PLANE, NOT BRAKED AND WITH
NO LOAD ON FORKS. Boom fully in and down.
2.
Check the tires pressure. All tires must have the correct inflate pressure.
3.
If machine doesn’t have stabs but it has a leveling system, please level the
machine referring to the bubble inside the cab.
If machine doesn’t have stabs nor a leveling system, please skip to next point.
4.