Beruflich Dokumente
Kultur Dokumente
PaperID [A08011
( P l e a s ef i l l t h i s P a p e r l D i n O M R S h e e t )
Section- A
Ql) (10x2:20)
a) Find the ratio of secondmomentof areaaboutthe centroidalaxis to the
secondmomentof areaaboutthe baseof a rectanslewith base:200 mm
and depth: 600 mm.
b) A bar 40 mm in diameteris subjectedto an axial load of 40 kN. The
extensionof the bar over a gaugelength of 200 mm is 0.3 mm. The
decreasein diameteris 0.018mm. Find the Poisson'sratio.
c) A simply supportedbeam of uniform cross-sectionis subjectedto a
maximumbendingmomentof 22.5kNm.If its cross-section is a hollow
tubewith outerdiameter40 mm andinnerdiameter2,0mm,find the value.
of maximum bendingstress.
d) A cantilever beam of uniform EI has a span equal to 'L'. An upward
force W acts at the midpoint of the beamand a downward force P acts
at the free end.In orderthat the deflectionat the free end is zero.find the
relationbetweenP and W.
e) Find the ratio of the torsionalmomentsof resistanceof a solid circular
shaftof diameter'D' anda hollow circularshafthavins externaldiameter
'D' and internaldiameter'd'.
Section- B
(4x5:20)
BC Solid d : 1 2c m
CD Solid d:9.6cm
If the angle of twist is samefor eachsection,determinethe lengthsof each
section.Find the value of appliedtorqueandtotal angleof twist if maximum
shearstressin hollow sectionis limited to 50MPa.G: 84GPa.
E-485
Section- C
(2 x 10: 20)
Q7) The aluminum and bronze cylindersare centeredand securedbetweentwo
rigid endplatesby tighteningthe two steelbolts,as shownin Fig.l . Thereis
no axial load in the assemblyat 50oF. Find the stressin the steelbolts when
the temperatureis increasedto 200" F. use the followine data
A(mm2) cr (/'F) E(GPa)
AluminiumCylinder t290 1 2 . 8x 1 0 - 6 70
BronzeCylinder r935 1 0 . 5x 1 0 - 6 83
Eachsteelbolt 485 6.5 x 10-6 200
(Ftstf
(Alldlmensionsin mm)
QB) Ditect stressesof 160 MPa tensileand 120 MPa compressiveexist on two
perpendicularplanesat a certainpoint in a body.They are also accompanied
by shearstresseson the planes.The greatestprincipal stressat the point due
to theseis 200 MPa.
(a) What must be the magnitudeof the shearingstresseson the two planes?
(b) What will be the maximum shearingstressand the associatednormal
stressat the point?
Use the Mohr's circle approach.Show the resultson properlyroriented
elements.
*{+*
8.485 3