Beruflich Dokumente
Kultur Dokumente
Página 1 de 4
Shutdown SIS
Previous Screen
Product: TRUCK
Model: 793C TRUCK ATY
Configuration: 793C Off-Highway Truck ATY00001-UP (MACHINE)
POWERED BY 3516 Engine
i01823682
Illustration 1 g00928358
Typical top view of the steering linkage
https://sis2001.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/... 06/03/2006
PDF created with pdfFactory trial version www.pdffactory.com
793C Off-Highway Truck ATY00001-UP (MACHINE) POWERED BY 3516 Engine(... Página 2 de 4
Procedure
1. Lift the front of the truck until the front wheels are off the ground and the strut rods in the
suspension cylinders are fully extended.
3. Measure distance (F) between the front tires at the front. Mark the measurement locations of
distance (F) on the front of each tire.
5. Measure distance (B) between the marks on the back of each tire that were made in Step 3.
6. Use Table 1 to determine the correct toe-out when the front wheels are off the ground.
Table 1
Correct Toe-Out
B = F - 48.2 mm (1.90 inch)
7. If the difference that was found in the previous step is not correct, adjust each link assembly by
the same number of turns.
Note: After the adjustment has been made, the tie rods must be of equal length.
8. Use the procedure in "Clamp Positioning" to align the tie rod with the clamp assembly. Failure to
correctly locate the clamp assembly on the tie rod could shorten the service life of the tie rod
assembly.
Clamp Positioning
https://sis2001.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/... 06/03/2006
PDF created with pdfFactory trial version www.pdffactory.com
793C Off-Highway Truck ATY00001-UP (MACHINE) POWERED BY 3516 Engine(... Página 3 de 4
Illustration 2 g00928375
View A-A
1. Position the clamp assembly (4) on tie rod (3). Refer to Illustration 2.
https://sis2001.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/... 06/03/2006
PDF created with pdfFactory trial version www.pdffactory.com
793C Off-Highway Truck ATY00001-UP (MACHINE) POWERED BY 3516 Engine(... Página 4 de 4
Illustration 3 g00928376
(3) Tie rod
(5) Nut
2. Align the open portion of the clamp assembly (4) with one of the slots in tie rod (3). Refer to
Illustration 3.
Reference: Refer to Specifications, "Steering Linkage and Cylinder Mounting" for additional
information.
Copyright 1993 - 2006 Caterpillar Inc. Mon Mar 6 19:24:47 EST 2006
All Rights Reserved.
Private Network For SIS Licensees.
https://sis2001.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/... 06/03/2006
PDF created with pdfFactory trial version www.pdffactory.com