Beruflich Dokumente
Kultur Dokumente
Installation Guide:
HypervsnTM Model M with Dome
1. TECHNICAL SPECIFICATIONS. . . . . . . . . . . . . . . . . . . . . . . . 3
2. PACKAGE CONTENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
DOME . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
6. DISPOSAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
1. TECHNICAL SPECIFICATIONS
Table 1. Basic technical specifications
Device noise figure with a dome does not exceed the natural noise level
2. PACKAGE CONTENTS
Table 2. Package contents
3 Gloves 2 pairs
6 Nut M5 4 pieces
Before assembling, make sure you have the following items at hand:
Nut M5 4 pieces
Undo 4 screws on the backside of the Stator and take off the wall mount
bracket
Pass the power cord through the hole in the Dome base
Attach the Dome base and the Stator using M4-12 screws
Remove protective film from the inside of the Dome (Use antistatic duster
prior to doing that not to damage the unit)
Attach the assembled structure and the Dome with M5-16 screws and M5
nuts so that the Device is positioned inside the Dome. Please note that M5
nut needs to lie on the back side of the Dome. The screw head and the nut
must not be in contact with the Dome, so make sure you use the nylon
washers included
After the assembly and installation of the Device with the Dome refer to
paragraph 7 of HypervsnTM Model M Operating Manual in order to proceed
further.
4. TECHNICAL MAINTENANCE OF
HYPERVSNTM MODEL M WITH DOME
Visual check of the power cord. The power cord should not have any cracks or
cuts compromising its base isolation. If there are any of such damages, please
fix them or replace the cord.
Visual check of the Dome integrity. If the Dome has any cracks bigger than 20
mm, it needs to be replaced.
Checking the Dome’s fittings. Restore any missing fittings, if at least one of the
them is missed. Tighten the fittings if necessary.
Cleaning the Dome from dust and dirt. Use glass cleansers and a clean
microfiber cloth or terry cloth. Glass cleanser can be applied directly onto the
Dome.
6. DISPOSAL
The sign on the Device or its package means that the Dome cannot be
disposed as Domestic waste. The Dome should be treated as other plastic
material.
HEADQUARTERS