Beruflich Dokumente
Kultur Dokumente
WELL DATA :
PUMP PRESSURE WHILE DRILLING. 2600 psi at 80 spm. APL = 310 psi
ANNULAR VOLUMES.
Drill pipe - Casing = 0.0505 bbls/ft
Drill pipe - Open hole = 0.0459 bbls/ft
Drill collars - Open hole = 0.0292 bbls/ft
bbls
bbls
mins
mins
ppg
psi
psi
8. After reaching FCP it is decided to increase the pump speed to 40 spm. What would happen to
BHP if the choke operator attempts to try and hold drill pipe pressure constant at the original FCP
value.
a. Increase
b. Decrease
c. Remain constant because drill pipe pressure was not changed.
9. What is the hydrostatic pressure at the bottom of the hole before the kick was taken.
psi
10. What is the ECD on bottom while drilling.
ppg
11. At 80 spm what is the annular velocity around the drill collars.
ft/min
ppg
ft
psi/ft
stks
stks
17. How long would it take to go from bit to shoe at a pump speed of 30 spm.
mins
mins
19. If the casing shoe was tested with a 12.5 ppg mud in the hole. How much pressure was applied
at the surface to give a fracture gradient of .91 psi/ft.
psi
20. What would be the new MAASP once the well has been killed.
psi
21. At 30 spm how long will it take to pump kill mud to the bit.
mins
22. What would be the pressure step down per 100 strokes.