Beruflich Dokumente
Kultur Dokumente
Time cycle Pre Load = 1.916 Secs Application Time = 2.298 Secs. Dwell Time = 3.337 Secs.
o o
The temperature during the calibration ranged from 25.6 C to 26.1 C
o
with a rate of change less than 2 C per hour
## -0.013 0.001191911 -0
Force Readings during indentation of Reference Blocks
Block 0 Degrees (kgf) 0 Degrees (kgf) 180 Degrees (kgf) Mean (kgf) Bias (kgf) Unc (kgf) % Error
Hard Block 150.184 150.163 150.190 150.1790 0.1790 0.3258 0.12%
Soft Block 150.200 150.146 150.140 150.1620 0.1620 0.3275 0.11%
COMMENTS
Hysterisis
Average of the last three readings performed = 99.73
CERTIFICATE OF CALIBRATION
CERTIFICATE NUMBER
12345
UKAS ACCREDITATION CALIBRATION LABORATORY No. 0574
PAGE 3 OF 5 PAGES
The above Rockwell hardness testing machine has been indirectly verified to the standard requirements of
ASTM E18.
The hardness tests were made using certified indenters. Certified hardness reference blocks were also
used. The serial numbers and assigned hardness values of the reference blocks together with the
measurements obtained are given in the table on page 2 of this certificate.
A direct verification was carried out to ASTM E18. Reference certificate number 12345
Dated :- 10 August 2017
Note! This indirect certificate becomes invalid if an indenter other than one certified by a BS EN ISO 17025
accedited laboratory is used.
Repeatability
Mean of Uncertainty
Allowed error
Block Scale Serial Reading Reading Reading Reading Reading
Error
the of the Mean k
& Value Number 1 2 3 4 5
readings Readings
3
Max Unc
64.5 HRC EP17193754 64.7 64.6 64.7 64.7 64.8 64.70 0.36 2.00 -0.20 0.20 0.5
45.3 HRC EP17193751 45.2 45.5 45.5 45.6 45.7 45.50 0.30 2.00 -0.20 0.50 1.0
24.8 HRC EP17193750 24.5 24.8 24.8 24.9 25.1 24.82 0.30 2.16 -0.02 0.60 1.0
Max Unc
#REF!
Note! The readings above have not been corrected for the BIAS of the machine obtained during the direct verification.
Date of Date of
10-Aug-17 00-Jan-00
Calibration Calibration
COMMENTS
0