Beruflich Dokumente
Kultur Dokumente
OCSET
BOOT1
RT8870A
COMP
YMDNN : Date Code
RGND
ISN0
ISN1
ISP0
ISP1
TON
GQW
FB
YMDNN 40 39 38 37 36 35 34 33 32 31
RBIAS 1 30 UGATE1
EN 2 29 PHASE1
SVC 3 28 PGND1
SVD 4 27 LGATE1
PWROK 5
GND
26 PVCC
PGOOD 6 25 LGATE0
VFIX/DRPSEL 7 24 PGND0
OCSET_NB 8
41
23 PHASE0
VCC 9 22 UGATE0
FB_NB 10 21 BOOT0
11 12 13 14 15 16 17 18 19 20
COMP_NB
TON_NB
ISP_NB
ISN_NB
RGND_NB
PGND_NB
LGATE_NB
UGATE_NB
BOOT_NB
PHASE_NB
WQFN-40L 5x5
9 VCC RBIAS 1
RT8870A
5V
26 PVCC
VIN
TON 37
5V to 25V
VIN 12 TON_NB
UGATE0 22
19 UGATE_NB BOOT0 21
20 BOOT_NB L1
PHASE0 23 VDD
L3
VDDNB 18 PHASE_NB
LGATE0 25
17 LGATE_NB
16
PGND_NB PGND0 24
optional NTC
13 ISP_NB
ISP0 36
14
ISN_NB
ISN0 35
VDDNB
VIN
VDDNB_FB_H
11
COMP_NB UGATE1 30
BOOT1 31
10 L2
NTC FB_NB
VDDNB_FB_L
15 PHASE1 29
RGND_NB
5V LGATE1 27
NTC NTC
PGND1 28
ISP1 33
40
OCSET ISN1 32
8
OCSET_NB VDD
7
VFIX/DRPSEL
3.3V
38
COMP VDD_FB_H
6
PGOOD PGOOD
5 NTC
PWROK PWROK FB 39
VDDIO 34
RGND VDD_FB_L
3
SVC SVC
2 Chip Enable
4 EN
SVD SVD
GND
41(Exposed Pad)
To be continued
www.richtek.com DS8870A-P00 July 2010
4
Preliminary RT8870A
FB FB_NB ONE_PHASE
BOOT0
UGATE0
Power On
VFIX/DRPSEL OCP OCP TON PHASE0
Reset &
SVI SLAVE BUS Setting Setting Generation PVCC
RGND Central Logic
DAC
LGATE0
RGND_NB PGND0
BOOT1
VREF
VREF_NB
+ +
- - UGATE1
ONE_PHASE
No Droop
PWMCP Driver
Logic PHASE1
+ Control
- LGATE1
PGND1
+
Protection/Fault + BOOT_NB
(OVP, NVP, -
- PWMCP UGATE_NB
Out-of-Spec, OTP)
PHASE_NB
LGATE_NB
PGND_NB
RBIAS IBIAS Generation NO
DROOP
+ ISP0
10
ERROR AMP - ISN0
Offset
+
+
FB - Cancellation NO
DROOP
COMP + ISP1
10
- ISN1
COMP_NB NO
DROOP
ERROR AMP
+ Offset + ISP_NB
10
FB_NB - Cancellation - ISN_NB
Electrical Characteristics
(VCC = VPVCC = 5V, VIN = 12V, TA = 25°C, unless otherwise specified)
Parameter Symbol Test Conditions Min Typ Max Unit
Supply Input
Supply Voltage V CC 4.5 5 5.5 V
Supply Current IVCC+PVCC VEN = 3.3V, Not Switching -- -- 10 mA
Shutdown Current IVCC+PVCC VEN = 0V -- -- 1 μA
Soft-Start/Soft-Shutdown Slew Rate Control
Soft-Start / Soft-Shutdown
SRSS 1.25 1.875 2.5 mV/μs
Voltage Transition
To be continued
DS8870A-P00 July 2010 www.richtek.com
7
RT8870A Preliminary
To be continued
www.richtek.com DS8870A-P00 July 2010
8
Preliminary RT8870A
Parameter Symbol Test Conditions Min Typ Max Unit
Negative Voltage Protection
VNVP −100 -70 -- mV
Threshold
Negative Voltage Protection
ΔVNVP -- 50 -- mV
Hysteresis
Current Limit Threshold VILIMIT = VISPx − VISNx,
VILIMIT 31.5 35 38.5 mV
Voltage (per phase) VOCSET = 2.1V
Thermal Shut-Down
TSD -- 160 -- °C
Threshold
Thermal Shut-Down
ΔTSD -- 10 -- °C
Hysteresis
Logic Inputs
EN Input Logic-High VIH With Respect to 3.3V 2 -- -- V
Threshold
Voltage Logic-Low VIL With Respect to 3.3V -- -- 0.8 V
EN Leakage Current −1 -- 1 μA
SEE DETAIL A
D D2
L
1
E E2
1 1
2 2
e b
DETAIL A
A Pin #1 ID and Tie Bar Mark Options
A3
A1 Note : The configuration of the Pin #1 identifier is optional,
but must be located within the zone indicated.
Information that is provided by Richtek Technology Corporation is believed to be accurate and reliable. Richtek reserves the right to make any change in circuit
design, specification or other related things if necessary without notice at any time. No third party intellectual property infringement of the applications should be
guaranteed by users when integrating Richtek products into any application. No legal responsibility for any said applications is assumed by Richtek.