Beruflich Dokumente
Kultur Dokumente
ERRATA NO. 1 TO “MORD SPECIFICATIONS FOR RURAL ROADS (FIRST REVISION)”- 2014
Page 81 Title of Table 400.3 - A “Grading Requirements for Surface Gravel” may be read as:
“Grading Requirements of Gravel for Surface Course”
Page 89 Table 400.5 may be read as:
Table 400.5 Grading Limits of Material for Stabilisation with Cement
63 mm 90-100
2) 63 mm to 45 mm 53 mm 25-75
45 mm 0-15
22.4 mm 0-5
63 mm 100
53 mm 95-100
3) 53 mm to 22.4 mm 45 mm 65-90
22.4 mm 0-10
11.2 mm 0-5
IS Sieve Designation Cumulative Percent by Weight of Total Aggregates Passing for the
(mm) Following Nominal Sizes (mm)
19 13 10 6
26.5 100 - - -
19.0 85-100 100 - -
13.2 0-40 85-100 100 -
9.5 0-7 0-40 85-100 100
6.3 - 0-7 0-35 85-100
4.75 - - 0-10 -
3.35 - - - 0-35
2.36 0-2 0-2 0-2 0-10
0.60 - - - 0-2
0.075 0-1.5 0-1.5 0-1.5 1-5
Minimum 65% by weight Passing 19 mm, retained Passing 13.2 mm, Passing 9.5 mm, Passing 6.3 mm retained
of aggregate 13.2 mm retained 9.5 mm retained 6.3 mm on 3.35 mm
Highest Mean Air Temperature < 20ºC 20ºC to 35ºC Above 35ºC
Lowest Mean Air Temp >.10 < .10 >-10≤10 >.10
Sl. Characteristics Specified values for the bitumen Method of IS Ref to
No. No. Annexure
(1) (2) (3) (4) (5) (6) (7)
i) Penetration at 25ºC, 0.1 mm, 100g, 5s 60 to 120 50 to 80 30 to 50 1203
ii) Softening point, (R&B), ºC, Min. 50 55 60* 1205 -
iii) FRAASS* breaking point, ºC, Max. -20 -16 -12 9381 -
iv) Flash Point, COC, ºC, Min. 220 220 220 1209 -
v) Elastic recovery of half thread in 50 60 60 2
ductilometer at 15ºC, percent, min.
vi) Complex modulus (G*/sin δ) as Min 1.0 58 70 76 1
kPa at 10 rad/s, at a temperature, ºC