Beruflich Dokumente
Kultur Dokumente
AC 100-240V
EXPLANATION OF LED STATUS
Power Jack
Cell 2 LED Indicator LED green blinking The charger is ready to charge.
Cell 1 LED Indicator
LED glows constant red The charger is charging in CC mode.
Cell 3 LED Indicator Charge Status LED
Battery Type Switch LED glows constant orange The charger is charging in CV mode.
Cell 4 LED Indicator
LED glows constant green. The charging process finishes.
Status LED Indicator
LED glows constant red. The cell is charging.
Cell Status LED
LED flashes red The cell is discharging.
* Error Message
XH Balance Socket If the charger encounters a problem, all LEDs will flash red in sequence to alert you to the errors. In this
Battery Socket case, please disconnect the power cord from the wall socket and unplug the battery from the charger.
-1- -2-
INSTRUCTION MANUAL 4) Connect battery lead to charger’s battery socket.
5) The charger starts charging. The charge status LED will glow constant red.
6) When the battery is fully charged, the charge status LED will glow constant green.
7) Unplug the battery from the charger and the charge status LED will flash green which indicates the
charger is ready to charge another battery.
2-4S NiMH/NiCD Balance Charger
INTRODUCTION
CAUTION:
Thank you for your choice of the UP4AC-N, 100-240V AC balance charger. This unit is simple to use but
its operation does require some knowledge on the part of the user. Please read this entire operating Please use the correct way to connect your battery to the UP4AC-N charger while charging.
manual completely and attentively before using this product, as it covers a wide range of information on Failure to connect will damage this charger.
operating and safety.
UP4AC-N Charger is an economic, high quality 100-240V AC balance charger, designed for charging
NiMH and NiCD batteries from 4-8 cells in balance mode. The circuit power is 20W and max charge
current can reach to 3A. There are three different charge current 1A/2A/3A which can be selected. You EXPLANATION OF LED STATUS
could select the proper charge current according to battery capacity.
CHARGE LED STATUS CHARGE STATUS
AC 100-240V LED Flashes Green The Charger is Ready to Charge
Power Jack
LED Glows Red The Charger is Charging
LED Glows Green The Charger Finished Charging Process
* Error Message
The charge current can’t be changed during charging process. If you change it, the charge status LED will
flash red to alert you to the error. In this case, please disconnect the power cord from the wall socket and
unplug the battery from the charger. You need to restart the charger to make it work again.
-1- -2-