Beruflich Dokumente
Kultur Dokumente
In our labs we we’re suppose to get use to using CLI commands and setup our routers with
static routing. The 2 points that are important to passing my CCNA exam would be
knowing how to set up a router using CLI commands and knowing exactly how to set up a
static route.
Static Routing
Router(config)#do sh ip route
This is the command to check if the .3 network has been added to the table or not.
Key Configurations:
In many of the labs a specific sequence of commands is needed to accomplish a task, such as
setting up a route filters. List the order and purpose of each step. This can be referenced to a
separate section of your journal.
Setting up IP address, subnet mask, clock rate, turning serial port on, and checking to see
if all is correct.
What went right was I was able to configure the routers and pc’s with the correct networks
and IP address. But my networks weren’t able to ping each other even after setting up
RIP. I found out that during the RIP process I was suppose to enter all the network that
was connected to the router. So I went back into each router and added the networks that
were missing. This solved my problem I was able to ping from pc to pc, router to pc, and
router to router over the whole network.
Summary of Results:
Summarize how this labs in this chapter may or may not help you in a job environment.
These labs give me practice in exactly what I will be doing in a real job environment.
Everything that I have done in these labs I am 100% certain I will do over and over again
when I get a job in the IT networking field.