Beruflich Dokumente
Kultur Dokumente
Create a coin-operated WiFi vending machine with few simple steps. You can also
download the guide in PDF format.
Raspberry Pi 3 Model B or B+
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 1/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
Others
This is used to power the coin acceptor. You must identify the positive and ground
terminal using voltmeter.
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 2/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
Needed softwares:
After downloading the needed softwares, we need to flash the installer into the midro
SD card using Etcher. To do so, unzip the contents of adopisowifi.zip
Insert the micro SD card into the your computer using a card reader.
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 3/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
Click the Flash! button and wait for the process to finish.
NOTE:
If you encounter prompts about formatting your sd card, just click Cancel.
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 4/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
IMPORTANT:
Turn on the raspberry pi and wait for the AdoPisoWifi WiFi network to appear, it may
take a couple of minutes.
Connect to the wifi network using your laptop or smartphone. Once connected, open a
browser and go to http://10.0.0.1/admin
username: admin
password: admin
(The machine is also accessible in your ethernet using its WAN IP.)
After successful login, go to Timer Settings and at the bottom of the page, set
Coinslot Sensor to version 2.
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 5/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
Connect all the connections base on the circuit diagram. Make sure to check the
positive ang negative terminal of the 12V DC power supply for the coinslot to work
properly.
Note:
Raspberry will use it's built-in wifi module to broadcast the SSID. But its signal is very
weak and recommended only for testing purposes. It is best to upgrade the antenna
usingexternal access point / CPE antenna to extend the wifi range and speed of
your wifi vending machine.
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 6/7
6/10/2018 How To Make WiFi Vending Machine using Raspberry Pi
http://localhost:4444/articles/how-to-make-wifi-vendo-using-raspberry-pi/ 7/7