Unequipped (MODEM-A) Alarm Reserved and installed optional package is removed from optional slot. MJ Type Mismatch(MODEM-A) Alarm The equipped type of interface is different from configured type. MJ Communication FAIL(MODEM-A) Alarm Communication failure of equipment internal control communication. MJ Module(MODEM-A) Alarm Equipment fault MJ BUS ERROR TX Alarm Data communication BUS failure condition in TX direction from STM-1 Card. MJ BUS ERROR RX Alarm Data communication BUS failure condition in RX direction from STM-1 Card. MJ RXSW STATUS Status Radio interface RX SW usage state in Redundant configuration - LOSS OF FRAME Alarm Loss of Frame at radio side. MJ FRAME ID Alarm Frame ID (route differentiation ID) MJ HIBER ALM Alarm Radio signal degradation (High BER threshold detection). (Threshold :1E-3/1E-4/1E-5) MJ LOBER ALM Alarm Radio signal degradation (Low BER threshold detection). (Threshold. :1E-6/1E-7/1E-8/1E-9) MN EARLY WARNING Alarm Radio signal degradation (Early Warning threshold detection). (Threshold :1E-9) MN MOD Alarm Indicates the operating status of the MOD. When any failure occurs in the modulator section, “Alarm” is issued. MJ IF CABLE SHORT Alarm IF cable between IDU - ODU is in short condition. MJ In - Phase indicates the received signal DADE status between No.1 and No.2 MODEM interfaces are in Phase condition. In this INPHASE. Status - condition, hitless switch over is available. L2SYNC LOSS Alarm Loss of frame synchronization of GFP frames on MODEM port. MJ RDI Alarm RDI indication reception alarm on MODEM port MJ UAE. Alarm UAE alarm. Indicates the occurrence of an Unavailable state. MN Mismatch condition when the mapping number of E1 channels are different between TX and RX modem ports or mismatch TDM/AMR Range Mismatch Alarm MJ condition of selected RX AMR modulation range and TX AMR modulation range. TX SW Reverse Request Status TXSW request signal receiving condition from the opposite station: - TX SW Lock in Status Status TXSW Lockin state - Unlocked Alarm Wireless synchronization status of the local side. MJ MODEM PS OFF Status Indicate power off condition of power switch which is in front of MODEM-A card. -