Beruflich Dokumente
Kultur Dokumente
1. Sensible heat factor is given by (where S.H. = Sensible heat, and L.H. = Latent heat)
A. (Please refer www.indiabix.com)
Answer: Option A
2. Stefan-Boltzmann law is applicable for heat transfer by convection.
B. Disagree
Answer: Option B
3.The most commonly used method for the design of duct size is the
C. static regain method
Answer: Option C
4. In counter-current flow heat exchangers
A. both the fluids at inlet are in their hottest state
Answer: Option A
5. The rate of heat flow through a body is . The term x/kA is known as
B. thermal resistance
Answer: Option B
6. In a vapour compression system, the condition of refrigerant is dry saturated vapour
A. before entering the compressor
Answer: Option A
7. An evaporator is also known as
A. freezing coil
B. cooling coil
C. chilling coil
D. all of these
Answer: Option D
8. The rate of heat flow through a body is . The term is known as temperature gradient.
A. Yes
Answer: Option A
Page 16 of 20
Heat Transfer Refrigeration And Air Conditioning
9. Oil separator in a refrigeration cycle is installed
B. between compressor and condenser
Answer: Option B
10. In larger industrial and commercial reciprocating compression systems, refrigerent widely used is
A. ammonia
Answer: Option A
11. During sensible cooling of air, specific humidity
A. remains constant
Answer: Option A
12. The transfer of heat by molecular collision is known as
A. conduction
Answer: Option A
13. When tc1 and tc2 are the temperatures of cold fluid at entry and exit respectively and th1 and th2 are the temperatures of hot fluid at entry and exit
point, and cold fluid has lower heat capacity rate as compared to hot fluid, then effectiveness of the heat exchanger is given by
D. (Please refer www.indiabix.com)
Answer: Option D
14. In a psychrometric chart, specific humidity (moisture content) lines are
B. horizontal and uniformly spaced
Answer: Option B
15. The expression Q = ρ AT4 is called (Please refer www.indiabix.com)
B. Stefan-Boltzmann equation (Please refer www.indiabix.com)
Answer: Option B
16. Thermal conductivity of solid metals __________ with rise in temperature.
B. decreases
Answer: Option B
17. The horizontal and non-uniformly spaced lines on a psychrometric chart indicates
C. dew point temperature
Answer: Option C
18. A reversible engine has ideal thermal efficiency of 30%. When it is used as a refrigerating machine with all other conditions unchanged, the
coefficient of performance will be
B. 2.33 (Please refer www.indiabix.com)
Answer: Option B
19. Which of the following refrigerant is highly toxic and flammable?
A. Ammonia
Answer: Option A
20. The unit of Stefan-Boltzmann constant is
C. Watt/m2K4 (Please refer www.indiabix.com)
Answer: Option C
21. The emissive power of a body depends upon its
A. temperature
B. physical nature
C. wave length
D. all of these
Answer: Option D
22. An electric cable of aluminium conductor (k = 240 W/mK) is to be insulated with rubber (k = 0.15 W/mK). The cable is to be located in air (h = 6
W/m2). The critical thickness of insulation will be
A. 25 mm
Answer: Option A
23. A cube at high temperature is immersed in a constant temperature bath. It loses heat from its top, bottom and side surfaces with heat transfer
coefficients of h1, h2 and h3 respectively. The average heat transfer coefficient for the cube is