Beruflich Dokumente
Kultur Dokumente
GE Document Z00-35-T010-316
Control Panel Drawings
GE Part Number : Z3200 0001
Rev 1
NOT a b
Ct. 11377
1 of 5
RC 04/11/2016 ZP-11377-35-101
Panel Power Up
Panel Ready
DI
SW1 Power On 15s Temp
A HMI Heater On
DI
PB1 Power Up 5s
Temp
= HMI Heater Off
Panel Sleep
DI
PB1 Power Up 20s A
DT
300s Panel Sleep
Ct. 11377
2 of 5
RC 04/11/2016 ZP-11377-35-101
TAHH 1101
Shutdowns
TAHH 1102
TAHH 1501
TAHH 1502
TAHH 1503
TALL 1503
ESD Local Emergency Stop
TAHH 0601 OR ESD Shutdown
Remote Emergency Stop
TAHH 0701
DI
TAHH 0904 ZSC 1101 60s
DI
FALL 0701 ZSC 1501 60s
OR
DI
FALL 0702 ZSO 1501 60s
DI
LALL 0701 ZSC 1502 60s
DI
LAHH 1101 ZSO 1502 60s
3 of 5
VAHH 0601
Functional Logic Diagram
1 Issued ZLA 04/11/16 ZLA 04/11/2016
RC 04/11/2016 ZP-11377-35-101
Purge Sequence Pre-Lube Sequence Crank Sequence
Panel Ready Pre-Lube
Suction Purge Req
A Pressure
> Setpoint Permissive Engine
Pre-Lube Pump On = 0 RPM
Delay RPM Starter On
HMI Start
DT 120s
Blowdown
Suction Purge Req Suction
< > Required
Pressure Setpoint Pressure Blowdown Valve Open
Setpoint
Pre-Lube Engine
Pre-Lube
< Oil Pressure Pre-Lube Permissive SE-0001 RPM = 0 Failure To Crank
Oil Pressure
Setpoint Failure
DT
Ignition On
20s
Fuel On
Bypass Valve Open Delay Timer
PO 3s
Purge
Suction Permissive
Pressure
< Purge Permissive Failure Crank Disc
Setpoint Engine
< RPM
RPM Setpoint
Purge
Suction Permissive
Pressure Setpoint
Crank Rest
PO 3s
Crank Number of
Attempts
= Cranks Engine Overcrank
Ct. 11377
4 of 5
RC 04/11/2016 ZP-11377-35-101
Warm-Up Loading Normal Shutdown
Suction Valve Open HMI Stop Recycle Valve Ramp Open
Starter Off Shutdown
Page 4 K
Discharge Valve Open 1.8 V IGTB Governor
Pre-Lube Pump On
Loading Bypass Valve Close
Unit
Run Status On
Warm-Up Blowdown Valve Close Cooldown
Fault Shutdown Indication Off Timer
PO 30s
K
1.8 V IGTB Governor
Engine
Ignition Off
RPM
SE-0001 RPM < Setpoint Loss of Speed Shutdown
Suction Bypass Valve Open
PID
Suction Valve Close
Activate Class B1 & B2
K Recycle Valve
Lockout Timers Discharge Valve Close
Discharge
PID Blowdown Valve Open
Engine Oil
TE-0707 Temp 90
Blowdown
Suction
< Required Blowdown Valve Closed
Pressure
Speed Setpoint
Control
Panel Ready
Ct. 11377
5 of 5
RC 04/11/2016 ZP-11377-35-101