Beruflich Dokumente
Kultur Dokumente
WIRING DIAGRAM
21
13
L4 S28 EXI4
BC
24 H4
L4 GND 4
L4
15
LO
2 LO
C132923E03
INSPECTION PROCEDURE
NOTICE:
When replacing the master cylinder solenoid, perform zero point calibration (See page BC-20).
BC–136 BRAKE CONTROL – VEHICLE STABILITY CONTROL SYSTEM
NG Go to step 4
C121700E97
OK
3 RECONFIRM DTC
B END
4WD Control (4WD) Switch Harness Side (a) Disconnect the 4WD control (4WD) switch connector.
Connector Front View: (b) Measure the resistance according to the value(s) in the
table below.
Standard resistance
Tester Connection Specified Condition
F11 F11-4 (GND) - Body ground Below 1 Ω
OK
BC
5 INSPECT 4WD CONTROL SWITCH
OK
OK
BC–138 BRAKE CONTROL – VEHICLE STABILITY CONTROL SYSTEM
7 CHECK HARNESS AND CONNECTOR (4WD CONTROL ECU - 4WD CONTROL SWITCH)
F9-15 (LO)
NG REPAIR OR REPLACE HARNESS OR
4WD Control (L4) Switch Harness Side Connector
CONNECTOR
Front View:
F11
BC LO
I045763E06
OK
8 CHECK HARNESS AND CONNECTOR (SKID CONTROL ECU - 4WD CONTROL ECU)
F9-24
(L4)
I045765E03
OK
BRAKE CONTROL – VEHICLE STABILITY CONTROL SYSTEM BC–139
S28
EXI4
ECM Harness View:
BC
E6-13 (L4)
I045573E04
Result
Condition Proceed to
OK (When troubleshooting in accordance with the DTC CHART.) A
OK (When troubleshooting in accordance with the PROBLEM
B
SYMPTOMS TABLE.)
NG C
END