Beruflich Dokumente
Kultur Dokumente
Introduction to
Draw panels and
Different drawing
tools
LAB#03
Submitted by;
Rana Mudassir
18-ME-95
Section: B
Submitted to;
Engnr. Rehan Sagheer
Procedure:
Step 1;
First of all select a line from panel draw a horizontal
line of 20 mm and
then a vertical line of 20 mm perpendicular to it and
then a line of 30 mm at an angle of 30o
to first line.
Step 2;
Then draw another line of 30mm which is at an angle
of 60o to the previous line.
Step 3;
Now draw a line of 20 mm vertically and draw
another line of 20mm perpendicular to it.
Step 4;
Repeated the above procedure three times. Finally, we got our figure.
Original figure
Procedure:
Step 1;
First of all draw a line of 20mm vertical and then from its
top end draw 30mm towards right horizontal line.
Step 2;
From the end of horizontal line draw a 15mm vertical line
upward
line upward.
Step 3;
Then draw a vertical line downward of 65mm .
Step 4;
Now draw a line from the end point of the last line to the initial line.
Step 5;
Finally we get our required figure according to the given dimensions.
Original figure;
Procedure:
Step 1;
First of all, draw an equilateral triangle of 60mm.
Step 2;
Find the point of intersection of the vertices of the
triangle. To get the Centre point of triangle.
Step 3;
Now draw a circle that touches the sides of the triangle
internally.
Step 4;
Draw two circles of radius 10 mm at the vertices of lower
left corner and upper corner.
Step 5;
Draw a circle of radius 15mm at the right corner
Original figure;
Procedure:
Step 1;
Draw two points at a distance of 90 mm apart.
Step 2;
Now draw circles of radii 30mm and 20 mm at left
hand side point.
Step 3;
And draw two circles of radii 10 mm and 20 mm at
right hand side point.
Step 4;
Draw the tangents line that touches the concentric circles.
Step 5;
Finally we get our required figure.
Original figure;